Ethanol to diesel: a sustainable alternative for the heavy-duty transportation sector

Restrepo-Flórez, Juan-Manuel; Cuello-Penaloza, Paolo; Canales, Emmanuel; Witkowski, Dustin; Rothamer, David A.; Huber, George W.; Maravelias, Christos T.

doi:10.1039/d2se01377k

Title: Ethanol to diesel: a sustainable alternative for the heavy-duty transportation sector

Journal Article · Wed Dec 07 00:00:00 EST 2022 · Sustainable Energy & Fuels

DOI:https://doi.org/10.1039/d2se01377k· OSTI ID:1922361

^[1]; Cuello-Penaloza, Paolo ^[1]; Canales, Emmanuel ^[1]; Witkowski, Dustin ^[1]; Rothamer, David A. ^[1];

^[1];

^[2]

Univ. of Wisconsin, Madison, WI (United States)
Princeton Univ., NJ (United States)

The combustion of middle distillates (diesel and jet fuel) is responsible for the emission of more than 2 GTon of CO₂ per year worldwide. While sustainable alternatives exist for gasoline and jet fuel, we still lack sustainable alternatives for diesel. This fact is especially relevant if we consider that electrification of sectors where diesel is used is challenging. One sustainable approach for diesel production is the catalytic upgrading of ethanol. While most work in this field has focused on the dehydration/oligomerization of ethanol, this approach is limited to producing fuels that have a high degree of branching and low cetane number. Another approach is the sequential use of ethanol Guerbet coupling, leading to higher alcohols, followed by etherification, leading to large ethers which, importantly, result in a product with high cetane number. In this work, we explore the catalytic upgrading of ethanol into diesel following an approach based on the initial Guerbet coupling of ethanol followed by etherification. The results presented are a collaborative and synergic effort among process and systems engineers, experimentalist in the area of catalysis, and fuel property modelers. Here, we demonstrate experimentally the feasibility of upgrading ethanol into a diesel fuel with properties that surpass its fossil counterpart. The diesel produced has a predicted cetane number of ~70 and outstanding cold flow properties, while maintaining other properties (viscosity, density, and flash point) within expected ranges. A technoeconomic analysis performed based on a detailed biorefinery model shows that the MFSP is ~5.89$ per Gal in 2021 dollars when lignocellulosic ethanol is used, with the most relevant economic driver the cost of the ethanol feedstock. The upgrading process can be performed with a net energy gain (EROI = 1.49 > 1). An LCA analysis of greenhouse gas (GHG) emissions reveals that the use of lignocellulosic ethanol may lead to more than 50% reduction in GHG emissions compared to fossil diesel. Depending on the CO₂ emissions associated with the production of ethanol we show that in some instances the production of carbon neutral diesel fuel is possible.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Univ. of Wisconsin, Madison, WI (United States)

Sponsoring Organization:: USDOE Office of Energy Efficiency and Renewable Energy (EERE)

Grant/Contract Number:: EE0008480

OSTI ID:: 1922361

Alternate ID(s):: OSTI ID: 1903391

Journal Information:: Sustainable Energy & Fuels, Vol. 7, Issue 3; ISSN 2398-4902

Publisher:: Royal Society of ChemistryCopyright Statement

Country of Publication:: United States

Language:: English

References (67)

Recent Advances in Catalytic Conversion of Ethanol to Chemicals Sun, Junming; Wang, Yong ACS Catalysis, Vol. 4, Issue 4 https://doi.org/10.1021/cs4011343	journal	March 2014
Flow reactor synthesis of cetane-enhancing fuel additive from 1-butanol Samoilov, Vadim O.; Ramazanov, Dzhamalutdin N.; Nekhaev, Andrey I. Fuel Processing Technology, Vol. 140 https://doi.org/10.1016/j.fuproc.2015.08.021	journal	December 2015
Catalytic Upgrading of Bioethanol to Fuel Grade Biobutanol: A Review Galadima, Ahmad; Muraza, Oki Industrial & Engineering Chemistry Research, Vol. 54, Issue 29 https://doi.org/10.1021/acs.iecr.5b01443	journal	July 2015
Oligomerization of .alpha.-olefins to higher oligomers Skupinska, Jadwiga. Chemical Reviews, Vol. 91, Issue 4 https://doi.org/10.1021/cr00004a007	journal	June 1991
Life cycle assessment of lignocellulosic ethanol: a review of key factors and methods affecting calculated GHG emissions and energy use Gerbrandt, Kelsey; Chu, Pei Lin; Simmonds, Allison Current Opinion in Biotechnology, Vol. 38 https://doi.org/10.1016/j.copbio.2015.12.021	journal	April 2016
The pinch design method for heat exchanger networks Linnhoff, B.; Hindmarsh, E. Chemical Engineering Science, Vol. 38, Issue 5 https://doi.org/10.1016/0009-2509(83)80185-7	journal	January 1983
Improving economics of lignocellulosic biofuels: An integrated strategy for coproducing 1,5-pentanediol and ethanol Huang, Kefeng; Won, Wangyun; Barnett, Kevin J. Applied Energy, Vol. 213 https://doi.org/10.1016/j.apenergy.2017.11.002	journal	March 2018
EROI of different fuels and the implications for society Hall, Charles A. S.; Lambert, Jessica G.; Balogh, Stephen B. Energy Policy, Vol. 64 https://doi.org/10.1016/j.enpol.2013.05.049	journal	January 2014
Comparison of U.S. Midwest corn stover ethanol greenhouse gas emissions from GREET and GHGenius Obnamia, Jon Albert; Dias, Goretty M.; MacLean, Heather L. Applied Energy, Vol. 235 https://doi.org/10.1016/j.apenergy.2018.10.091	journal	February 2019
Reaction of ethanol over hydroxyapatite affected by Ca/P ratio of catalyst Tsuchida, T.; Kubo, J.; Yoshioka, T. Journal of Catalysis, Vol. 259, Issue 2 https://doi.org/10.1016/j.jcat.2008.08.005	journal	October 2008
Upgrading ethanol to n-butanol over highly dispersed Ni–MgAlO catalysts Pang, Jifeng; Zheng, Mingyuan; He, Lei Journal of Catalysis, Vol. 344 https://doi.org/10.1016/j.jcat.2016.08.024	journal	December 2016
Ethanol condensation at elevated pressure over copper on AlMgO and AlCaO porous mixed-oxide supports Petrolini, Davi D.; Eagan, Nathaniel; Ball, Madelyn R. Catalysis Science & Technology, Vol. 9, Issue 8 https://doi.org/10.1039/C9CY00316A	journal	January 2019
Animals vs. artifacts: Which are more diverse? [Opinion] Smil, Vaclav IEEE Spectrum, Vol. 56, Issue 8 https://doi.org/10.1109/MSPEC.2019.8784118	journal	August 2019
Performance-advantaged ether diesel bioblendstock production by a priori design Huq, Nabila A.; Huo, Xiangchen; Hafenstine, Glenn R. Proceedings of the National Academy of Sciences, Vol. 116, Issue 52 https://doi.org/10.1073/pnas.1911107116	journal	December 2019
Ethanol as a Renewable Building Block for Fuels and Chemicals Dagle, Robert A.; Winkelman, Austin D.; Ramasamy, Karthikeyan K. Industrial & Engineering Chemistry Research, Vol. 59, Issue 11 https://doi.org/10.1021/acs.iecr.9b05729	journal	February 2020
Designing production-optimal alternative fuels for conventional, flexible-fuel, and ultra-high efficiency engines König, Andrea; Siska, Maximilian; Schweidtmann, Artur M. Chemical Engineering Science, Vol. 237 https://doi.org/10.1016/j.ces.2021.116562	journal	June 2021
Techno-economic and environmental assessment of renewable jet fuel production in integrated Brazilian sugarcane biorefineries Klein, Bruno Colling; Chagas, Mateus Ferreira; Junqueira, Tassia Lopes Applied Energy, Vol. 209 https://doi.org/10.1016/j.apenergy.2017.10.079	journal	January 2018
Oligomerization of ethanol-derived propene and isobutene mixtures to transportation fuels: catalyst and process considerations Saavedra Lopez, Johnny; Dagle, Robert A.; Dagle, Vanessa Lebarbier Catalysis Science & Technology, Vol. 9, Issue 5 https://doi.org/10.1039/C8CY02297F	journal	January 2019
Catalytic synthesis of distillate-range ethers and olefins from ethanol through Guerbet coupling and etherification Eagan, Nathaniel M.; Moore, Benjamin M.; McClelland, Daniel J. Green Chemistry, Vol. 21, Issue 12 https://doi.org/10.1039/C9GC01290G	journal	January 2019
2016 Billion-Ton Report: Advancing Domestic Resources for a Thriving Bioeconomy Langholtz, M. H.; Stokes, B. J.; Eaton, L. M. https://doi.org/10.2172/1271651 DOE/EE-1440	report	July 2016
Integrated design of processes and products: Optimal renewable fuels König, Andrea; Neidhardt, Lisa; Viell, Jörn Computers & Chemical Engineering, Vol. 134 https://doi.org/10.1016/j.compchemeng.2019.106712	journal	March 2020
Carbon-Negative Biofuel Production Kim, Seungdo; Zhang, Xuesong; Reddy, Ashwan Daram Environmental Science & Technology, Vol. 54, Issue 17 https://doi.org/10.1021/acs.est.0c01097	journal	August 2020
Applications of light olefin oligomerization to the production of fuels and chemicals Nicholas, Christopher P. Applied Catalysis A: General, Vol. 543 https://doi.org/10.1016/j.apcata.2017.06.011	journal	August 2017
Effect of increased fuel volatility on CDC operation in a light-duty CIDI engine Groendyk, M.; Rothamer, D. Fuel, Vol. 194 https://doi.org/10.1016/j.fuel.2016.12.064	journal	April 2017
Heterogeneous Catalysts for the Guerbet Coupling of Alcohols Kozlowski, Joseph T.; Davis, Robert J. ACS Catalysis, Vol. 3, Issue 7 https://doi.org/10.1021/cs400292f	journal	June 2013
Chemistries and processes for the conversion of ethanol into middle-distillate fuels Eagan, Nathaniel M.; Kumbhalkar, Mrunmayi D.; Buchanan, J. Scott Nature Reviews Chemistry, Vol. 3, Issue 4 https://doi.org/10.1038/s41570-019-0084-4	journal	March 2019
Life cycle assessment of CO ₂ capture and utilization: a tutorial review von der Assen, Niklas; Voll, Philip; Peters, Martina Chem. Soc. Rev., Vol. 43, Issue 23 https://doi.org/10.1039/C3CS60373C	journal	January 2014
Lessons from Commercialization of Cellulosic Ethanol – A POET Perspective Slupska, Margaret; Bushong, Dave Biofuels, Bioproducts and Biorefining, Vol. 13, Issue 4 https://doi.org/10.1002/bbb.2033	journal	July 2019
Development of a genome-editing CRISPR/Cas9 system in thermophilic fungal Myceliophthora species and its application to hyper-cellulase production strain engineering Liu, Qian; Gao, Ranran; Li, Jingen Biotechnology for Biofuels, Vol. 10, Issue 1 https://doi.org/10.1186/s13068-016-0693-9	journal	January 2017
Successive vapour phase Guerbet condensation of ethanol and 1-butanol over Mg-Al oxide catalysts in a flow reactor Larina, Olga V.; Valihura, Karina V.; Kyriienko, Pavlo I. Applied Catalysis A: General, Vol. 588 https://doi.org/10.1016/j.apcata.2019.117265	journal	November 2019
Biodiesel production through the use of different sources and characterization of oils and their esters as the substitute of diesel: A review Singh, S. P.; Singh, Dipti Renewable and Sustainable Energy Reviews, Vol. 14, Issue 1 https://doi.org/10.1016/j.rser.2009.07.017	journal	January 2010
One-step continuous process for the production of 1-butanol and 1-hexanol by catalytic conversion of bio-ethanol at its sub-/supercritical state Ghaziaskar, Hassan S.; Xu, Chunbao (Charles) RSC Advances, Vol. 3, Issue 13 https://doi.org/10.1039/c3ra00134b	journal	January 2013
A systems level analysis of ethanol upgrading strategies to middle distillates Restrepo-Flórez, Juan-Manuel; Ryu, Joonjae; Witkowski, Dustin Energy & Environmental Science, Vol. 15, Issue 10 https://doi.org/10.1039/D2EE02202H	journal	January 2022
Hydrocarbon bio-jet fuel from bioconversion of poplar biomass: techno-economic assessment Crawford, Jordan T.; Shan, Chin Wei; Budsberg, Erik Biotechnology for Biofuels, Vol. 9, Issue 1 https://doi.org/10.1186/s13068-016-0545-7	journal	June 2016
Economic, energetic, and environmental analysis of lignocellulosic biorefineries with carbon capture Geissler, Caleb H.; Maravelias, Christos T. Applied Energy, Vol. 302 https://doi.org/10.1016/j.apenergy.2021.117539	journal	November 2021
Well-to-wheels energy use and greenhouse gas emissions of ethanol from corn, sugarcane and cellulosic biomass for US use Wang, Michael; Han, Jeongwoo; Dunn, Jennifer B. Environmental Research Letters, Vol. 7, Issue 4 https://doi.org/10.1088/1748-9326/7/4/045905	journal	December 2012
Oligomerization of ethene over nickel-exchanged zeolite y into a diesel-range product Heveling, Josef; van der Beek, Adriaan; de Pender, Marcel Applied Catalysis, Vol. 42, Issue 2 https://doi.org/10.1016/0166-9834(88)80011-3	journal	September 1988
A general model for predicting the flash point of miscible mixtures Liaw, Horng-Jang; Chiu, Yi-Yu Journal of Hazardous Materials, Vol. 137, Issue 1 https://doi.org/10.1016/j.jhazmat.2006.01.078	journal	September 2006
Reaction chemistry of ethanol oligomerization to distillate-range molecules using low loading Cu/MgxAlOy catalysts Cuello-Penaloza, Paolo A.; Chavarrio-Cañas, Javier; Du, Yi Applied Catalysis B: Environmental, Vol. 318 https://doi.org/10.1016/j.apcatb.2022.121821	journal	December 2022
Dehydration of C ₅ −C ₁₂ Linear 1-Alcohols over η-Alumina to Fuel Ethers Nel, Reinier J. J.; de Klerk, Arno Industrial & Engineering Chemistry Research, Vol. 48, Issue 11 https://doi.org/10.1021/ie801930r	journal	June 2009
Updated US and Canadian normalization factors for TRACI 2.1 Ryberg, Morten; Vieira, Marisa D. M.; Zgola, Melissa Clean Technologies and Environmental Policy, Vol. 16, Issue 2 https://doi.org/10.1007/s10098-013-0629-z	journal	May 2013
Economic and energetic analysis of biofuel supply chains Ng, Rex T. L.; Maravelias, Christos T. Applied Energy, Vol. 205 https://doi.org/10.1016/j.apenergy.2017.08.161	journal	November 2017
Continuous condensed-phase ethanol conversion to higher alcohols: Experimental results and techno-economic analysis Nezam, Iman; Peereboom, Lars; Miller, Dennis J. Journal of Cleaner Production, Vol. 209 https://doi.org/10.1016/j.jclepro.2018.10.276	journal	February 2019
Alternative thermochemical routes for aviation biofuels via alcohols synthesis: Process modeling, techno-economic assessment and comparison Atsonios, Konstantinos; Kougioumtzis, Michael-Alexander; D. Panopoulos, Kyriakos Applied Energy, Vol. 138 https://doi.org/10.1016/j.apenergy.2014.10.056	journal	January 2015
Conversion of 1-hexanol to di-n-hexyl ether on acidic catalysts Medina, Eduardo; Bringué, Roger; Tejero, Javier Applied Catalysis A: General, Vol. 374, Issue 1-2 https://doi.org/10.1016/j.apcata.2009.11.024	journal	February 2010
Towards a green bulk-scale biobutanol from bioethanol upgrading Zhang, Qi; Dong, Jing; Liu, Yongmei Journal of Energy Chemistry, Vol. 25, Issue 6 https://doi.org/10.1016/j.jechem.2016.08.010	journal	November 2016
Ethylene Oligomerization beyond Schulz–Flory Distributions Britovsek, George J. P.; Malinowski, Robert; McGuinness, David S. ACS Catalysis, Vol. 5, Issue 11 https://doi.org/10.1021/acscatal.5b02203	journal	October 2015
Compendium of Experimental Cetane Numbers Yanowitz, Janet; Ratcliff, Matthew A.; McCormick, Robert L. https://doi.org/10.2172/1345058	report	February 2017
Simple Method to Evaluate and to Predict Flash Points of Organic Compounds Carroll, Felix A.; Lin, Chung-Yon; Quina, Frank H. Industrial & Engineering Chemistry Research, Vol. 50, Issue 8 https://doi.org/10.1021/ie1021283	journal	March 2011
Using waste CO2 to increase ethanol production from corn ethanol biorefineries: Techno-economic analysis Huang, Zhe; Grim, Gary; Schaidle, Joshua Applied Energy, Vol. 280 https://doi.org/10.1016/j.apenergy.2020.115964	journal	December 2020
Cloud point prediction of fuels and fuel blends Mirante, Fátima I. C.; Coutinho, João A. P. Fluid Phase Equilibria, Vol. 180, Issue 1-2 https://doi.org/10.1016/S0378-3812(01)00352-1	journal	April 2001
Integrated Catalytic Conversion of γ-Valerolactone to Liquid Alkenes for Transportation Fuels Bond, J. Q.; Alonso, D. M.; Wang, D. Science, Vol. 327, Issue 5969, p. 1110-1114 https://doi.org/10.1126/science.1184362	journal	February 2010
Condensed-Phase Ethanol Conversion to Higher Alcohols over Bimetallic Catalysts Nezam, Iman; Zak, Jason; Miller, Dennis J. Industrial & Engineering Chemistry Research, Vol. 59, Issue 31 https://doi.org/10.1021/acs.iecr.0c01748	journal	July 2020
Comparative techno‐economic analysis and process design for indirect liquefaction pathways to distillate‐range fuels via biomass‐derived oxygenated intermediates upgrading Tan, Eric C. D.; Snowden‐Swan, Lesley J.; Talmadge, Michael Biofuels, Bioproducts and Biorefining, Vol. 11, Issue 1 https://doi.org/10.1002/bbb.1710	journal	September 2016
Vapor-phase methanol and ethanol coupling reactions on CuMgAl mixed metal oxides Bravo-Suárez, Juan J.; Subramaniam, Bala; Chaudhari, Raghunath V. Applied Catalysis A: General, Vol. 455 https://doi.org/10.1016/j.apcata.2013.01.025	journal	March 2013
Methodology for the experimental measurement of vapor–liquid equilibrium distillation curves using a modified ASTM D86 setup Ferris, Alison M.; Rothamer, David A. Fuel, Vol. 182 https://doi.org/10.1016/j.fuel.2016.05.099	journal	October 2016
Greening Ammonia toward the Solar Ammonia Refinery Wang, Lu; Xia, Meikun; Wang, Hong Joule, Vol. 2, Issue 6 https://doi.org/10.1016/j.joule.2018.04.017	journal	June 2018
UNIFAC—VISCO group contribution method for predicting kinematic viscosity: extension and temperature dependence Gaston-Bonhomme, Y.; Petrino, P.; Chevalier, J. L. Chemical Engineering Science, Vol. 49, Issue 11 https://doi.org/10.1016/0009-2509(94)80065-0	journal	June 1994
Synthesis of Biomass‐Derived Ethers for Use as Fuels and Lubricants Rorrer, Julie E.; Bell, Alexis T.; Toste, F. Dean ChemSusChem, Vol. 12, Issue 13 https://doi.org/10.1002/cssc.201900535	journal	May 2019
Ethanol to distillate-range molecules using Cu/MgxAlOy catalysts with low Cu loadings Cuello-Penaloza, Paolo A.; Dastidar, Raka G.; Wang, Shao-Chun Applied Catalysis B: Environmental, Vol. 304 https://doi.org/10.1016/j.apcatb.2021.120984	journal	May 2022
Silication of γ-alumina catalyst during the dehydration of linear primary alcohols Makgoba, N.; Sakuneka, T.; Koortzen, J. Applied Catalysis A: General, Vol. 297, Issue 2 https://doi.org/10.1016/j.apcata.2005.09.003	journal	January 2006
What is the Minimum EROI that a Sustainable Society Must Have? Hall, Charles; Balogh, Stephen; Murphy, David Energies, Vol. 2, Issue 1 https://doi.org/10.3390/en20100025	journal	January 2009
Co-optimization of Heavy-Duty Fuels and Engines: Cost Benefit Analysis and Implications Ou, Longwen; Cai, Hao; Seong, Hee Je Environmental Science & Technology, Vol. 53, Issue 21 https://doi.org/10.1021/acs.est.9b03690	journal	October 2019
The Alcohol‐to‐Jet Conversion Pathway for Drop‐In Biofuels: Techno‐Economic Evaluation Geleynse, Scott; Brandt, Kristin; Garcia‐Perez, Manuel ChemSusChem, Vol. 11, Issue 21 https://doi.org/10.1002/cssc.201801690	journal	October 2018
Techno-economic analysis for upgrading the biomass-derived ethanol-to-jet blendstocks Tao, Ling; Markham, Jennifer N.; Haq, Zia Green Chemistry, Vol. 19, Issue 4 https://doi.org/10.1039/C6GC02800D	journal	January 2017
Lifecycle greenhouse gas footprint and minimum selling price of renewable diesel and jet fuel from fermentation and advanced fermentation production technologies Staples, Mark D.; Malina, Robert; Olcay, Hakan Energy Environ. Sci., Vol. 7, Issue 5 https://doi.org/10.1039/C3EE43655A	journal	January 2014
Oligomerization of Monoolefins by Homogeneous Catalysts Forestière, A.; Olivier-Bourbigou, H.; Saussine, L. Oil & Gas Science and Technology - Revue de l'IFP, Vol. 64, Issue 6 https://doi.org/10.2516/ogst/2009027	journal	September 2009

Similar Records

Catalytic Upgrading of Ethanol to C8+ Distillate Range Ethers via Guerbet Coupling and Etherification

Conference · Mon Aug 22 00:00:00 EDT 2022 · OSTI ID:1922361

Huber, George; Canales, Emmanuel; Penaloza, Paolo Cuello; +6 more

A System Level Analysis of Ethanol Upgrading to Middle Distillates

Journal Article · Thu Sep 08 00:00:00 EDT 2022 · Energy & Environmental Science · OSTI ID:1922361

Restrepo Florez, Juan Manuel; Ryu, Joonjae; Witkowski, Dustin; +2 more

Catalytic upgrading of ethanol to C8+ distillate range ethers via Guerbet coupling and etherification

Conference · Tue Aug 15 00:00:00 EDT 2023 · OSTI ID:1922361

Huber, George; Canales, Emmanuel; Penaloza, Paolo Cuello; +7 more

Related Subjects

09 BIOMASS FUELS

Title: Ethanol to diesel: a sustainable alternative for the heavy-duty transportation sector

Citation Formats

References (67)

Similar Records

Related Subjects