Fuel property impacts on gaseous and PM emissions from a multi-mode single-cylinder engine

Park, Yeonshil; Moses-DeBusk, Melanie; Powell, Tommy; Szybist, James; Xiang, Zhanglohong; Zhu, Junqing; McEnally, Charles S.; Pfefferle, Lisa D.

doi:10.1016/j.fuel.2022.125641

Title: Fuel property impacts on gaseous and PM emissions from a multi-mode single-cylinder engine

Journal Article · Thu Sep 08 00:00:00 UTC 2022 · Fuel

DOI: https://doi.org/10.1016/j.fuel.2022.125641 · OSTI ID:1886505

Park, Yeonshil ^[1];

^[1]; Powell, Tommy ^[1];

^[1];

^[2]; Zhu, Junqing ^[2];

^[2]; Pfefferle, Lisa D. ^[2]

Oak Ridge National Lab. (ORNL), Oak Ridge, TN (United States)
Yale Univ., New Haven, CT (United States)

The U.S. Department of Energy’s Co-Optima initiative has focused on improving fuel economy and vehicle performance while reducing emissions through the simultaneous development of emerging sustainable fuels with beneficial properties and advanced combustion strategies. A major thrust has been the development of advanced compression ignition (ACI) combustion strategies of gasoline range fuels in combination with spark-ignited (SI) combustion in a single engine capable of multi-mode operation to achieve high power density with enhanced part load efficiency. The aim of this study was to further the understanding of how emissions from both ACI and SI strategies operating on the same fuels in the same engine are impacted by different fuel properties. This investigation focused on particulate matter (PM) and gaseous hydrocarbon emissions from 6 different fuels across 3 different combustion modes on the same single-cylinder engine designed for multi-mode operation: SI combustion, partial fuel stratification (PFS), and spark-assisted compression ignition (SACI). In each of these modes, 3 different CA50 phasings were studied such that all 6 fuels could be studied at the same phasings. Three of the six different fuels used were specially formulated in a previous investigation to study the impact of fuel distillation and aromatic content while maintaining the research octane number (RON) and octane sensitivity. Additionally, neat isooctane and two ethanol containing fuels (RD5-87 and Co-Optima E30) were studied. Different fuel and phasing impacts on emissions were observed across the three combustion modes. Fuel properties were found to impact soot PM and particle number more than the CA50 phasing, while the phasing had more impact on NOx emissions. The NOx emissions were reduced in the PFS mode for all fuels compared to SI combustion, but the SACI combustion mode did not reduce NOx emissions. Although PFS produced low soot PM emissions like SI, total PM mass emissions were significantly higher due to large organic carbon (OC) PM mass contribution. Both PFS and SACI had greater particle number emission than SI operation with small nuclei mode particles dominating in PFS compared to large agglomeration particles in SACI.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Oak Ridge National Laboratory (ORNL), Oak Ridge, TN (United States)

Sponsoring Organization:: USDOE Office of Energy Efficiency and Renewable Energy (EERE), Transportation Office. Bioenergy Technologies Office; USDOE Office of Energy Efficiency and Renewable Energy (EERE), Transportation Office. Vehicle Technologies Office

Grant/Contract Number:: AC05-00OR22725

OSTI ID:: 1886505

Journal Information:: Fuel, Journal Name: Fuel Journal Issue: 1 Vol. 331; ISSN 0016-2361

Publisher:: ElsevierCopyright Statement

Country of Publication:: United States

Language:: English

References (56)

Impacts of Air-Fuel Stratification in ACI Combustion on Particulate Matter and Gaseous Emissions Moses-DeBusk, Melanie; Curran, Scott J.; Lewis, Samuel A. Emission Control Science and Technology, Vol. 5, Issue 3 https://doi.org/10.1007/s40825-019-00122-5	journal	May 2019
Catalysts for automobile emission control Kummer, J. T. Progress in Energy and Combustion Science, Vol. 6, Issue 2 https://doi.org/10.1016/0360-1285(80)90006-4	journal	January 1980
Kinetic modeling of the interactions between NO and hydrocarbons at high temperature Frassoldati, A.; Faravelli, T.; Ranzi, E. Combustion and Flame, Vol. 135, Issue 1-2 https://doi.org/10.1016/S0010-2180(03)00152-4	journal	October 2003
An experimental and kinetic calculation of the promotion effect of hydrocarbons on the NO-NO2 conversion in a flow reactor Hori, Morio; Matsunaga, Naoki; Marinov, Nick Symposium (International) on Combustion, Vol. 27, Issue 1 https://doi.org/10.1016/S0082-0784(98)80427-X	journal	January 1998
Temperature dependence of NO to NO2 conversion by n-butane and n-pentane oxidation Hori, Morio; Koshiishi, Yasuhisa; Matsunaga, Naoki Proceedings of the Combustion Institute, Vol. 29, Issue 2 https://doi.org/10.1016/S1540-7489(02)80270-X	journal	January 2002
Physical and chemical effects of low octane gasoline fuels on compression ignition combustion Badra, Jihad; Viollet, Yoann; Elwardany, Ahmed Applied Energy, Vol. 183 https://doi.org/10.1016/j.apenergy.2016.09.060	journal	December 2016
Impact of ethanol blending into gasoline on aromatic compound evaporation and particle emissions from a gasoline direct injection engine Ratcliff, Matthew A.; Windom, Bret; Fioroni, Gina M. Applied Energy, Vol. 250 https://doi.org/10.1016/j.apenergy.2019.05.030	journal	September 2019
Gas- and particle-phase primary emissions from in-use, on-road gasoline and diesel vehicles May, Andrew A.; Nguyen, Ngoc T.; Presto, Albert A. Atmospheric Environment, Vol. 88 https://doi.org/10.1016/j.atmosenv.2014.01.046	journal	May 2014
Measuring and predicting sooting tendencies of oxygenates, alkanes, alkenes, cycloalkanes, and aromatics on a unified scale Das, Dhrubajyoti D.; St. John, Peter C.; McEnally, Charles S. Combustion and Flame, Vol. 190 https://doi.org/10.1016/j.combustflame.2017.12.005	journal	April 2018
Comprehensive modeling study analyzing the insights of the NO–NO2 conversion process in current diesel engines Benajes, J.; López, J. J.; Novella, R. Energy Conversion and Management, Vol. 84 https://doi.org/10.1016/j.enconman.2014.04.073	journal	August 2014
Effects of engine operating conditions on particle emissions of lean-burn gasoline direct-injection engine Park, Cheolwoong; Lee, Sunyoup; Yi, Uihyung Energy, Vol. 115 https://doi.org/10.1016/j.energy.2016.09.051	journal	November 2016
Some advantages and challenges of running a Euro IV, V6 diesel engine on a gasoline fuel Kalghatgi, G. T.; Kumara Gurubaran, R.; Davenport, A. Fuel, Vol. 108 https://doi.org/10.1016/j.fuel.2012.10.059	journal	June 2013
The effects of distillation characteristics and aromatic content on low-load gasoline compression ignition (GCI) performance and soot emissions in a multi-cylinder engine D. F. Chuahy, Flavio; Moses-DeBusk, Melanie; Curran, Scott J. Fuel, Vol. 299 https://doi.org/10.1016/j.fuel.2021.120893	journal	September 2021
Production, fuel properties and combustion testing of an iso-olefins blendstock for modern vehicles Dagle, Vanessa Lebarbier; Affandy, Martin; Lopez, Johnny Saavedra Fuel, Vol. 310 https://doi.org/10.1016/j.fuel.2021.122314	journal	February 2022
The effective density and fractal dimension of soot particles from premixed flames and motor vehicle exhaust Maricq, M. Matti; Xu, Ning Journal of Aerosol Science, Vol. 35, Issue 10 https://doi.org/10.1016/j.jaerosci.2004.05.002	journal	October 2004
What fuel properties enable higher thermal efficiency in spark-ignited engines? Szybist, James P.; Busch, Stephen; McCormick, Robert L. Progress in Energy and Combustion Science, Vol. 82 https://doi.org/10.1016/j.pecs.2020.100876	journal	January 2021
Advanced compression-ignition engines—understanding the in-cylinder processes Dec, John E. Proceedings of the Combustion Institute, Vol. 32, Issue 2 https://doi.org/10.1016/j.proci.2008.08.008	journal	January 2009
Sooting tendencies of co-optima test gasolines and their surrogates McEnally, Charles S.; Xuan, Yuan; St. John, Peter C. Proceedings of the Combustion Institute, Vol. 37, Issue 1 https://doi.org/10.1016/j.proci.2018.05.071	journal	January 2019
Ability of Particulate Matter Index to describe sooting tendency of various gasoline formulations in a stratified-charge spark-ignition engine Kim, Namho; Vuilleumier, David; He, Xu Proceedings of the Combustion Institute, Vol. 38, Issue 4 https://doi.org/10.1016/j.proci.2020.06.173	journal	January 2021
Impact of Selected High-Performance Fuel Blends on Three-Way Catalyst Light Off under Synthetic Spark-Ignition Engine-Exhaust Conditions Sinha Majumdar, Sreshtha; Pihl, Josh A. Energy & Fuels, Vol. 34, Issue 10 https://doi.org/10.1021/acs.energyfuels.0c02102	journal	September 2020
Numerical Investigation into Effects of Fuel Physical Properties on GCI Engine Performance and Emissions Badra, Jihad; Zubail, Abdullah; Sim, Jaeheon Energy & Fuels, Vol. 33, Issue 10 https://doi.org/10.1021/acs.energyfuels.9b02340	journal	September 2019
The Impact of Ethanol Fuel Blends on PM Emissions from a Light-Duty GDI Vehicle Maricq, M. Matti; Szente, Joseph J.; Jahr, Ken Aerosol Science and Technology, Vol. 46, Issue 5 https://doi.org/10.1080/02786826.2011.648780	journal	May 2012
Using a new inversion matrix for a fast-sizing spectrometer and a photo-acoustic instrument to determine suspended particulate mass over a transient cycle for light-duty vehicles Xue, Jian; Li, Yang; Quiros, David Aerosol Science and Technology, Vol. 50, Issue 11 https://doi.org/10.1080/02786826.2016.1239247	journal	October 2016
Elemental Carbon-Based Method for Monitoring Occupational Exposures to Particulate Diesel Exhaust Birch, M. E.; Cary, R. A. Aerosol Science and Technology, Vol. 25, Issue 3 https://doi.org/10.1080/02786829608965393	journal	January 1996
Particle measurement programme (PMP) light-duty inter-laboratory exercise: comparison of different particle number measurement systems Giechaskiel, Barouch; Dilara, Panagiota; Sandbach, Emma Measurement Science and Technology, Vol. 19, Issue 9 https://doi.org/10.1088/0957-0233/19/9/095401	journal	July 2008
Correlation Between Speciated Hydrocarbon Emissions and Flame Ionization Detector Response for Gasoline/Alcohol Blends Wallner, Thomas Journal of Engineering for Gas Turbines and Power, Vol. 133, Issue 8 https://doi.org/10.1115/1.4002893	journal	April 2011
Computational Fluid Dynamics Simulation of Gasoline Compression Ignition Kodavasal, Janardhan; Kolodziej, Christopher P.; Ciatti, Stephen A. Journal of Energy Resources Technology, Vol. 137, Issue 3 https://doi.org/10.1115/1.4029963	journal	May 2015
Assessment of Residual Mass Estimation Methods for Cylinder Pressure Heat Release Analysis of HCCI Engines With Negative Valve Overlap Ortiz-Soto, Elliott A.; Vavra, Jiri; Babajimopoulos, Aristotelis ASME 2011 Internal Combustion Engine Division Fall Technical Conference https://doi.org/10.1115/ICEF2011-60167	conference	February 2012
Impact of gasoline composition on particulate matter emissions from a direct-injection gasoline engine: Applicability of the particulate matter index Aikawa, Koichiro; Jetter, Jeff J. International Journal of Engine Research, Vol. 15, Issue 3 https://doi.org/10.1177/1468087413481216	journal	June 2013
A perspective on the range of gasoline compression ignition combustion strategies for high engine efficiency and low NOx and soot emissions: Effects of in-cylinder fuel stratification Dempsey, Adam B.; Curran, Scott J.; Wagner, Robert M. International Journal of Engine Research, Vol. 17, Issue 8 https://doi.org/10.1177/1468087415621805	journal	July 2016
Hydrocarbon impact on NO to NO₂ conversion in a compression ignition engine under low-temperature combustion Yu, Xiao; Yu, Shui; Zheng, Ming International Journal of Engine Research, Vol. 20, Issue 2 https://doi.org/10.1177/1468087417745441	journal	December 2017
A Historical Analysis of the Co-evolution of Gasoline Octane Number and Spark-Ignition Engines Splitter, Derek; Pawlowski, Alexander; Wagner, Robert Frontiers in Mechanical Engineering, Vol. 1 https://doi.org/10.3389/fmech.2015.00016	journal	January 2016
Octane Index Applicability over the Pressure-Temperature Domain Powell, Tommy R.; Szybist, James P.; Dal Forno Chuahy, Flavio Energies, Vol. 14, Issue 3 https://doi.org/10.3390/en14030607	journal	January 2021
Characterization of Pressure Waves in HCCI Combustion Eng, J. A. SAE Powertrain & Fluid Systems Conference & Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2002-01-2859	conference	October 2002
New Heat Transfer Correlation for an HCCI Engine Derived from Measurements of Instantaneous Surface Heat Flux Chang, Junseok; Güralp, Orgun; Filipi, Zoran 2004 Powertrain & Fluid Systems Conference & Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2004-01-2996	conference	October 2004
A Study of a Gasoline-fueled Compression Ignition Engine ∼ Expansion of HCCI Operation Range Using SI Combustion as a Trigger of Compression Ignition ∼ Urushihara, Tomonori; Yamaguchi, Koichi; Yoshizawa, Koudai SAE 2005 World Congress & Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2005-01-0180	conference	April 2005
Nitrogen Oxide Production in a Diesel Engine Fueled by Natural Gas Hill, P. G.; Mctaggart-Cowan, G. P. SAE Technical Paper Series https://doi.org/10.4271/2005-01-1727	conference	April 2005
Advantages of Fuels with High Resistance to Auto-ignition in Late-injection, Low-temperature, Compression Ignition Combustion Kalghatgi, Gautam T.; Risberg, Per; Ångström, Hans-Erik Powertrain & Fluid Systems Conference and Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2006-01-3385	conference	October 2006
CFD-Based Optimization of a Diesel-fueled Free Piston Engine Prototype for Conventional and HCCI Combustion Bergman, Miriam; Fredriksson, Jakob; Golovitchev, Valeri I. SAE International Journal of Engines, Vol. 1, Issue 1 https://doi.org/10.4271/2008-01-2423	journal	October 2008
Determination of Cycle Temperatures and Residual Gas Fraction for HCCI Negative Valve Overlap Operation Fitzgerald, Russell P.; Steeper, Richard; Snyder, Jordan SAE International Journal of Engines, Vol. 3, Issue 1 https://doi.org/10.4271/2010-01-0343	journal	April 2010
Cost and Fuel Economy Driven Aftertreatment Solutions -for Lean GDI- Pauly, Thomas; Franoschek, Stefan; Hoyer, Ruediger SAE 2010 World Congress & Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2010-01-0363	conference	April 2010
Study of Regulated and Non-Regulated Emissions from Combustion of Gasoline, Alcohol Fuels and their Blends in a DI-SI Engine Wallner, Thomas; Frazee, Richard International Powertrains, Fuels & Lubricants Meeting, SAE Technical Paper Series https://doi.org/10.4271/2010-01-1571	conference	May 2010
Development of a Predictive Model for Gasoline Vehicle Particulate Matter Emissions Aikawa, Koichiro; Sakurai, Takayuki; Jetter, Jeff J. SAE International Journal of Fuels and Lubricants, Vol. 3, Issue 2 https://doi.org/10.4271/2010-01-2115	journal	August 2010
Ethanol Blend Effects On Direct Injection Spark-Ignition Gasoline Vehicle Particulate Matter Emissions Storey, John M.; Barone, Teresa; Norman, Kevin SAE International Journal of Fuels and Lubricants, Vol. 3, Issue 2 https://doi.org/10.4271/2010-01-2129	journal	August 2010
Bridging the Gap between HCCI and SI: Spark-Assisted Compression Ignition Manofsky, Laura; Vavra, Jiri; Assanis, Dennis N. SAE 2011 World Congress & Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2011-01-1179	conference	April 2011
Gasoline Partially Premixed Combustion in a Light Duty Engine at Low Load and Idle Operating Conditions Borgqvist, Patrick; Tunestal, Per; Johansson, Bengt SAE Technical Paper Series https://doi.org/10.4271/2012-01-0687	conference	April 2012
On the Nature of Particulate Emissions from DISI Engines at Cold-Fast-Idle Ketterer, Justin E.; Cheng, Wai K. SAE International Journal of Engines, Vol. 7, Issue 2 https://doi.org/10.4271/2014-01-1368	journal	April 2014
Filter-based control of particulate matter from a lean gasoline direct injection engine Parks, James E.; Storey, John M. E.; Prikhodko, Vitaly Y. SAE 2016 World Congress and Exhibition, SAE Technical Paper Series https://doi.org/10.4271/2016-01-0937	conference	April 2016
Comparison of Hydrocarbon Measurement with FTIR and FID in a Dual Fuel Locomotive Engine Wright, Nolan; Osborne, Dustin; Music, Nathan SAE Technical Paper Series https://doi.org/10.4271/2016-01-0978	conference	April 2016
Characterization of Hydrocarbon Emissions from Gasoline Direct-Injection Compression Ignition Engine Operating on a Higher Reactivity Gasoline Fuel Storey, John; Lewis, Samuel; Moses-DeBusk, Melanie SAE International Journal of Engines, Vol. 10, Issue 4 https://doi.org/10.4271/2017-01-0747	journal	February 2017
Emission Performance of Low Cetane Naphtha as Drop-In Fuel on a Multi-Cylinder Heavy-Duty Diesel Engine and Aftertreatment System Lee, Jong; Zhang, Yu; Tzanetakis, Tom WCX™ 17: SAE World Congress Experience, SAE Technical Paper Series https://doi.org/10.4271/2017-01-1000	conference	April 2017
Detection of Polar Compounds Condensed on Particulate Matter Using Capillary Electrophoresis-Mass Spectrometry Lewis, Sam; Storey, John; Connatser, Raynella SAE Technical Paper Series https://doi.org/10.4271/2020-01-0395	conference	April 2020
Parametric Study to Optimize Gasoline Compression Ignition Operation under Low Load Condition Using CFD Badra, Jihad; Alhussaini, Alma; Sim, Jaeheon SAE Technical Paper Series https://doi.org/10.4271/2021-01-0440	conference	April 2021
Numerical Investigation on NO to NO₂ Conversion in a Low-Temperature Combustion CI Engine Gupta, Nupur; Yu, Xiao; Eaves, Nick SAE Technical Paper Series https://doi.org/10.4271/2021-01-0506	conference	April 2021
A Universally Applicable Equation for the Instantaneous Heat Transfer Coefficient in the Internal Combustion Engine Woschni, G. National Fuels and Lubricants, Powerplants, Transportation Meetings, SAE Technical Paper Series https://doi.org/10.4271/670931	conference	October 1967
Schlieren-Streak Measurements of Instantaneous Exhaust Gas Velocities from a Spark-Ignition Engine Yun, H. J.; Mirsky, W. International Automobile Engineering and Manufacturing Meeting, SAE Technical Paper Series https://doi.org/10.4271/741015	conference	October 1974

Similar Records

Fuel Effects on Advanced Compression Ignition Load Limits

Journal Article · Tue Sep 21 00:00:00 UTC 2021 · SAE Technical Paper Series · OSTI ID:1824985

Powell, Tommy; Szybist, James

Fuel Effects on Multimode Engine Operation (Sandia National Laboratories) (DOE VTO Annual Progress Report for FY21)

Technical Report · Wed Jun 01 04:00:00 UTC 2022 · OSTI ID:1871372

Sjoberg, Carl Magnus; Killingsworth, Nick; Kolodziej, Christopher; +4 more

Octane Index Applicability over the Pressure-Temperature Domain

Journal Article · Mon Jan 25 00:00:00 UTC 2021 · Energies · OSTI ID:1762529

Powell, Tommy R.; Szybist, James P.; Dal Forno Chuahy, Flavio; +4 more

Related Subjects

42 ENGINEERING
ACI
EC/OC
Emissions
HC speciation
Multi-mode
Particular matter

Title: Fuel property impacts on gaseous and PM emissions from a multi-mode single-cylinder engine

Citation Formats

References (56)

Similar Records

Related Subjects