Qualification High Voltage Testing of Short Triax HTS Cables in the Laboratory

Journal Article · Thu Jan 01 04:00:00 EST 2009 · IEEE Transactions on Applied Superconductivity

DOI:https://doi.org/10.1109/TASC.2009.2019646· OSTI ID:963715

James, David Randy ^[1]; Sauers, Isidor ^[1]; Ellis, Alvin R ^[1]; Tuncer, Enis ^[1]; Gouge, Michael J ^[1]; Demko, Jonathan A ^[1]; Duckworth, Robert C ^[1]; Rey, Christopher M ^[1]

---

1. ORNL

In order to qualify the electrical insulation design of future HTS cables installed in the electric grid, a number of high voltage qualification tests are generally performed in the laboratory on either single-phase model cables and/or actual three-phase cable samples. Prior to installation of the 200-m Triax HTS cable at the American Electric Power Bixby substation near Columbus, Ohio, in September, 2006, such tests were conducted on both single-phase model cables made at ORNL and tri-axial cable sections cut off from cable made on a production run. The three-phase tri-axial design provides some specific testing challenges since the ground shield and three phases are concentric about a central former with each phase separated by dielectric tape insulation immersed in liquid nitrogen. The samples were successfully tested and qualified for partial discharge inception, AC withstand, and lightning impulse where voltage is applied to one phase with the other phases grounded. In addition one of the phase pairs was tested for dc withstand as a ldquoworst caserdquo scenario to simulate the effect of VLF (Very Low Frequency) tests on the actual cable installed at the Bixby site. The model and prototype cables will be described and the high voltage test results summarized.

• Research Organization: Oak Ridge National Laboratory (ORNL)
• Sponsoring Organization: OE USDOE - Office of Electric Transmission and Distribution
• DOE Contract Number: AC05-00OR22725
• OSTI ID: 963715
• Journal Information: IEEE Transactions on Applied Superconductivity, Journal Name: IEEE Transactions on Applied Superconductivity Journal Issue: 3 Vol. 19
• Country of Publication: United States
• Language: English

Related Subjects

36 MATERIALS SCIENCE
CABLES
DESIGN
DIELECTRIC MATERIALS
ELECTRIC POWER
ELECTRICAL INSULATION
LIGHTNING
NITROGEN
OHIO
ORNL
PRODUCTION
SHIELDS
TESTING
high-temperature superconductors partial discharges power cable insulation power cable testing power grids superconducting cables