Comparative study of three yttrium organometallic compounds for the stabilization of the cubic phase in YSZ deposited by PE-CVD

Espinoza-Pérez, L. J.; López-Honorato, Eddie; González, Luis A.; García-Montalvo, Verónica

doi:10.1016/j.ceramint.2020.10.028

Comparative study of three yttrium organometallic compounds for the stabilization of the cubic phase in YSZ deposited by PE-CVD

Journal Article · Mon Feb 15 00:00:00 EST 2021 · Ceramics International

DOI:https://doi.org/10.1016/j.ceramint.2020.10.028· OSTI ID:1760141

Espinoza-Pérez, L. J. ^[1]; López-Honorato, Eddie ^[2]; González, Luis A. ^[1]; García-Montalvo, Verónica ^[3]

Centro de Investigación y de Estudios Avanzados Del IPN (CINVESTAV) (Mexico)
Centro de Investigación y de Estudios Avanzados Del IPN (CINVESTAV) (Mexico); Oak Ridge National Lab. (ORNL), Oak Ridge, TN (United States)
Instituto de Química, Universidad Nacional Autónoma de México (UNAM) (Mexico)

In this work, the efficiencies of three organometallic yttrium precursors used to produce YSZ coatings by plasma-enhanced chemical vapor deposition were studied. Yttrium (III) acetylacetonate, Y (acac)₃, yttrium (III) hexafluoroacetylacetonate, Y (acacF₆)₃, and yttrium (III) tris(2,2,6,6-tetramethyl-3,5-heptanedionate), Y (tmhd)₃, were used to stabilize the cubic phase in zirconia deposited at temperatures from 500 to 800 °C. Our results showed that at temperatures between 500 and 600 °C, Y (tmhd)₃ appeared to be the most efficient dopant as it introduced the highest concentration of yttria (1–2.7 mol%) with only 6.4–5.6 at.% carbon. However, at 700 and 800 °C, Y (acac)₃ introduced twice as much yttria (8–15 mol%) as Y (tmhd)₃ with almost the same amount of carbon (5.4–3 at.%). Conversely, Y (acacF6)3 was the least efficient as it maintained a low concentration of yttria of around 0.7–1.8 mol% with 3.6–8.2 at.% carbon for all the deposition temperatures. Among these precursors, only Y (acac)₃ surpassed 8 mol% yttria and achieved a fully stabilized cubic phase at 800 °C, with the remaining samples stabilizing only the tetragonal phase. The tetragonal phase was stabilized due to the formation of crystallites of around 10 nm. The observed difference in the efficiency of the three precursors was correlated to important differences in their decomposition behavior as observed by mass spectrometry and thermogravimetry/differential scanning calorimetry.

View Accepted Manuscript (DOE)

Research Organization:: Oak Ridge National Laboratory (ORNL), Oak Ridge, TN (United States)

Sponsoring Organization:: USDOE

Grant/Contract Number:: AC05-00OR22725

OSTI ID:: 1760141

Journal Information:: Ceramics International, Journal Name: Ceramics International Journal Issue: 4 Vol. 47; ISSN 0272-8842

Publisher:: ElsevierCopyright Statement

Country of Publication:: United States

Language:: English

References (42)

Raman and X-ray investigations of the incorporation of Ca2+ and Cd2+ in the ZrO2 structure Gazzoli, Delia; Mattei, Giorgio; Valigi, Mario Journal of Raman Spectroscopy, Vol. 38, Issue 7 https://doi.org/10.1002/jrs.1708	journal	January 2007
Phase relationships in the zirconia-yttria system Scott, H. G. Journal of Materials Science, Vol. 10, Issue 9 https://doi.org/10.1007/BF01031853	journal	September 1975
Crystalline structure of YSZ thin films deposited on Si(111) substrate by chemical vapor deposition Hwang, Sang-Chul; Lee, Hee-Gyoun; Shin, Hyung-Shik Korean Journal of Chemical Engineering, Vol. 15, Issue 3 https://doi.org/10.1007/BF02707078	journal	May 1998
Investigation of the structure and energy of β-diketonates. XIV. Composition of overheated vapors and the molecular structure of monomeric yttrium tris-hexafluoroacetylacetonate Y(C5O2HF6)3 Girichev, G. V.; Rybkin, V. V.; Tverdova, N. V. Journal of Structural Chemistry, Vol. 48, Issue 5 https://doi.org/10.1007/s10947-007-0122-9	journal	September 2007
Molten Salt Corrosion Resistance of Yttria Stabilized Zirconia Coating with Silicon Carbide Interlayer on High Density Graphite Jagadeeswara Rao, Ch.; Madhura, B.; Vetrivendan, E. Transactions of the Indian Institute of Metals, Vol. 71, Issue 5 https://doi.org/10.1007/s12666-017-1260-1	journal	January 2018
Corrosion of metallic materials in HTR-helium environments Graham, L. W. Journal of Nuclear Materials, Vol. 171, Issue 1 https://doi.org/10.1016/0022-3115(90)90350-V	journal	April 1990
Structural disorder and phase transitions in ZrO2-Y2O3 system Feinberg, A.; Perry, C. H. Journal of Physics and Chemistry of Solids, Vol. 42, Issue 6 https://doi.org/10.1016/0022-3697(81)90032-9	journal	January 1981
Determination of tetragonal-cubic phase boundary of BY Raman scattering Yashima, Masatomo; Ohtake, Katsuya; Kakihana, Masato Journal of Physics and Chemistry of Solids, Vol. 57, Issue 1 https://doi.org/10.1016/0022-3697(95)00085-2	journal	January 1996
Characterization of zirconium dioxide film formed by plasma enhanced metal-organic chemical vapor deposition Kim, Eui-Tae; Yoon, Soon-Gil Thin Solid Films, Vol. 227, Issue 1 https://doi.org/10.1016/0040-6090(93)90179-S	journal	May 1993
Deposition and structural characterization of ZrO2 and yttria-stabilized ZrO2 films by chemical vapor deposition Kim, J. S.; Marzouk, H. A.; Reucroft, P. J. Thin Solid Films, Vol. 254, Issue 1-2 https://doi.org/10.1016/0040-6090(94)06274-O	journal	January 1995
Metastable-stable phase diagrams in the zirconia-containing systems utilized in solid-oxide fuel cell application Yashima, M. Solid State Ionics, Vol. 86-88 https://doi.org/10.1016/0167-2738(96)00386-4	journal	July 1996
Thermal dissociation/surface ionization of organometallic compounds on the heated Re-oxide surface: carbonyls of Fe, Cr, Mn and Co, acetylacetonate complexes of Al, V, Cr and Zr, and lithium amides Fujii, Toshihiro; Kakizaki, Kouichi; Ishii, Hiroyuki Chemical Physics, Vol. 163, Issue 3 https://doi.org/10.1016/0301-0104(92)87121-O	journal	July 1992
Fractional sublimation of the β-diketone chelates of the lanthanide and related elements Berg, Eugene W.; Jaime Chiang Acosta, J. Analytica Chimica Acta, Vol. 40 https://doi.org/10.1016/S0003-2670(00)86700-8	journal	January 1968
Yttrium tetramethylheptanedionates: syntheses, crystal and molecular structures and thermal behaviours of Y(thd)3·H2O and Y(thd)3 (thd=tBuC(O)CHC(O)tBu) Gleizes, A.; Sans-Lenain, S.; Medus, D. Inorganica Chimica Acta, Vol. 209, Issue 1 https://doi.org/10.1016/S0020-1693(00)84979-8	journal	July 1993
Mass spectrometric behaviour of M(acac)3 complexes (M=Y, La, Ce, Pr, Nd, Sm, Eu, Gd, Tb, Dy, Ho, Er, Tm, Yb and Lu; acac=acetylacetonate ligand) in triethanolamine upon negative liquid secondary ion mass spectrometry Plaziak, Adam S.; Zeng, Chen-hui; Costello, Catherine E. Inorganica Chimica Acta, Vol. 184, Issue 2 https://doi.org/10.1016/S0020-1693(00)85075-6	journal	June 1991
Reaction of yttria-stabilized zirconia with zirconium, silicon and Zircaloy-4 at high temperature: a compatibility study for cermet fuels Arima, T.; Tateyama, T.; Idemitsu, K. Journal of Nuclear Materials, Vol. 319 https://doi.org/10.1016/S0022-3115(03)00129-6	journal	June 2003
Deposition and characterization of YSZ thin films by aerosol-assisted CVD Wang, H. B.; Xia, C. R.; Meng, G. Y. Materials Letters, Vol. 44, Issue 1 https://doi.org/10.1016/S0167-577X(99)00291-8	journal	May 2000
MOCVD deposition of YSZ on stainless steels Chevalier, S.; Kilo, M.; Borchardt, G. Applied Surface Science, Vol. 205, Issue 1-4 https://doi.org/10.1016/S0169-4332(02)01088-7	journal	January 2003
Molten salt corrosion of high density graphite and partially stabilized zirconia coated high density graphite in molten LiCl–KCl salt Sure, Jagadeesh; Ravi Shankar, A.; Ramya, S. Ceramics International, Vol. 38, Issue 4 https://doi.org/10.1016/j.ceramint.2011.11.051	journal	May 2012
Development of ZrO2 and YSZ coatings deposited by PE-CVD below 800 °C for the protection of Ni alloys Espinoza-Pérez, L. J.; López-Honorato, Eddie; González, Luis A. Ceramics International, Vol. 46, Issue 10 https://doi.org/10.1016/j.ceramint.2020.03.109	journal	July 2020
Low thermal conductivity of atomic layer deposition yttria-stabilized zirconia (YSZ) thin films for thermal insulation applications Cho, Jungwan; Park, Joonsuk; An, Jihwan Journal of the European Ceramic Society, Vol. 37, Issue 9 https://doi.org/10.1016/j.jeurceramsoc.2017.03.045	journal	August 2017
Corrosion of high temperature metallic materials in VHTR Cabet, C.; Rouillard, F. Journal of Nuclear Materials, Vol. 392, Issue 2 https://doi.org/10.1016/j.jnucmat.2009.03.029	journal	July 2009
Radiation damage in cubic-stabilized zirconia Costantini, Jean-Marc; Beuneu, François; Weber, William J. Journal of Nuclear Materials, Vol. 440, Issue 1-3 https://doi.org/10.1016/j.jnucmat.2013.02.041	journal	September 2013
Mechanism of plastic deformation of a Ni-based superalloy for VHTR applications Mo, Kun; Lovicu, Gianfranco; Chen, Xiang Journal of Nuclear Materials, Vol. 441, Issue 1-3 https://doi.org/10.1016/j.jnucmat.2013.03.083	journal	October 2013
The molten salt reactor (MSR) in generation IV: Overview and perspectives Serp, Jérôme; Allibert, Michel; Beneš, Ondřej Progress in Nuclear Energy, Vol. 77 https://doi.org/10.1016/j.pnucene.2014.02.014	journal	November 2014
Synthesis and thermal decomposition of a novel zirconium acetato-propionate cluster: [Zr12] Petit, Sarah; Morlens, Stéphanie; Yu, Zeming Solid State Sciences, Vol. 13, Issue 3 https://doi.org/10.1016/j.solidstatesciences.2010.12.041	journal	March 2011
MOCVD of thick YSZ coatings using acetylacetonates Samoilenkov, S. V.; Stefan, M. A.; Wahl, G. Surface and Coatings Technology, Vol. 192, Issue 1 https://doi.org/10.1016/j.surfcoat.2004.03.019	journal	March 2005
Large area zirconia coatings on galvanized steel sheet López Ibáñez, R.; Martín, F.; Ramos-Barrado, J. R. Surface and Coatings Technology, Vol. 202, Issue 11 https://doi.org/10.1016/j.surfcoat.2007.09.016	journal	February 2008
The Occurrence of Metastable Tetragonal Zirconia as a Crystallite Size Effect Garvie, Ronald C. The Journal of Physical Chemistry, Vol. 69, Issue 4 https://doi.org/10.1021/j100888a024	journal	April 1965
Monomeric malonate precursors for the MOCVD of HfO ₂ and ZrO ₂ thin films Pothiraja, Ramasamy; Milanov, Andrian; Parala, Harish Dalton Trans., Issue 4 https://doi.org/10.1039/B810528F	journal	January 2009
The deposition of cadmium selenide and cadmium phosphide thin films from cadmium thioselenoimidodiphosphinate by AACVD and the formation of an aromatic species Oyetunde, Temidayo; Afzaal, Mohammad; Vincent, Mark A. Dalton Transactions, Vol. 48, Issue 4 https://doi.org/10.1039/C8DT04357D	journal	January 2019
Molecular precursors for (nano) materials — a one step strategy Veith, Michael Journal of the Chemical Society, Dalton Transactions, Issue 12 https://doi.org/10.1039/b201383p	journal	May 2002
High-temperature corrosion characteristics of yttria-stabilized zirconia material in molten salts of LiCl-Li ₂ O and LiCl-Li ₂ O-Li Cho, Soo-Haeng; Kim, Dae-Young; Kwon, Sukcheol Journal of Nuclear Science and Technology, Vol. 55, Issue 1 https://doi.org/10.1080/00223131.2017.1383214	journal	September 2017
Radiation-induced synthesis of ZrO ₂ nanoparticles by thermal decomposition of zirconium acetylacetonate Mahfouz, R. M.; Ahmed, G. A. -W.; Al-Wassil, A. I. Radiation Effects and Defects in Solids, Vol. 168, Issue 11-12 https://doi.org/10.1080/10420150.2013.784909	journal	December 2013
A Study on the Thermal Stability to 1000°C of Various Carbon Allotropes and Carbonaceous Matter both Under Nitrogen and in air Cataldo, Franco Fullerenes, Nanotubes and Carbon Nanostructures, Vol. 10, Issue 4 https://doi.org/10.1081/FST-120016451	journal	December 2002
Quantification of Yttria in Stabilized Zirconia by Raman Spectroscopy Hemberger, Yannick; Wichtner, Nadja; Berthold, Christoph International Journal of Applied Ceramic Technology, Vol. 13, Issue 1 https://doi.org/10.1111/ijac.12434	journal	July 2015
Effect of Deposition Temperature on the Growth of Yttria-Stabilized Zirconia Thin Films on Si(111) by Chemical Vapor Deposition Hwang, Sang-Chul; Shin, Hyung-Shik Journal of the American Ceramic Society, Vol. 82, Issue 10 https://doi.org/10.1111/j.1151-2916.1999.tb02177.x	journal	October 1999
Characterization of zirconia coatings deposited by inductively coupled plasma assisted chemical vapor deposition Colpo, P.; Ceccone, G.; Sauvageot, P. Journal of Vacuum Science & Technology A: Vacuum, Surfaces, and Films, Vol. 18, Issue 4 https://doi.org/10.1116/1.582306	journal	July 2000
Materials Design for the Next Generation Thermal Barrier Coatings Clarke, D. R.; Levi, C. G. Annual Review of Materials Research, Vol. 33, Issue 1 https://doi.org/10.1146/annurev.matsci.33.011403.113718	journal	August 2003
Anode-supported planar solid oxide fuel cells by plasma-enhanced metalorganic chemical vapor deposition (PE-MOCVD) and electrostatic spray deposition (ESD): Fabrication of dense thin layers of yttria-stabilized zirconia by PE-MOCVD Giuseppe, Gianfranco Di; Selman, J. Robert Journal of Materials Research, Vol. 16, Issue 10 https://doi.org/10.1557/JMR.2001.0409	journal	October 2001
Preparation of Zirconia Nanofibers by Electrospinning and Calcination with Zirconium Acetylacetonate as Precursor Rodaev, Vyacheslav V.; Razlivalova, Svetlana S.; Zhigachev, Andrey O. Polymers, Vol. 11, Issue 6 https://doi.org/10.3390/polym11061067	journal	June 2019
Synthesis And Thermal Analysis Of Yttrium Metallorganic Complexes For Evaluation As Chemical Vapor Deposition Precursors Selvakumar, J. Advanced Materials Letters, Vol. 3, Issue 2 https://doi.org/10.5185/amlett.2011.7293	journal	April 2012

Similar Records

MOCVD OF YSZ COATINGS USING ?-DIKETONATE PRECURSORS

Journal Article · Wed Dec 31 23:00:00 EST 2008 · Journal of Alloys and Compounds · OSTI ID:947127

Transformation of yttrium-doped hydrated zirconium into tetragonal and cubic nanocrystalline zirconia

Journal Article · Sun Jan 31 23:00:00 EST 1999 · Journal of Solid State Chemistry · OSTI ID:329188

The crystal structure and morphology of NiO-YSZ composite that prepared from local zircon concentrate of Bangka Island

Journal Article · Tue Mar 29 00:00:00 EDT 2016 · AIP Conference Proceedings · OSTI ID:22590840

Related Subjects

36 MATERIALS SCIENCE
Cubic phase
Thermal behavior
YSZPE-CVD
Yttrium organometallic compounds
Zirconia

Comparative study of three yttrium organometallic compounds for the stabilization of the cubic phase in YSZ deposited by PE-CVD

Citation Formats

References (42)

Similar Records

Related Subjects