Robust passivation of CdSeTe based solar cells using reactively sputtered magnesium zinc oxide

Yeung, Gavin; Reich, Carey; Onno, Arthur; Bothwell, Alexandra; Danielson, Adam; Holman, Zachary; Sampath, Walajabad S.; Wolden, Colin A.

doi:10.1016/j.solmat.2021.111388

Title: Robust passivation of CdSeTe based solar cells using reactively sputtered magnesium zinc oxide

Journal Article · Mon Sep 20 00:00:00 UTC 2021 · Solar Energy Materials and Solar Cells

DOI: https://doi.org/10.1016/j.solmat.2021.111388 · OSTI ID:1977659

^[1]; Reich, Carey ^[2]; Onno, Arthur ^[3];

^[2]; Danielson, Adam ^[2];

^[3]; Sampath, Walajabad S. ^[2];

^[4]

Colorado School of Mines, Golden, CO (United States); OSTI
Colorado State Univ., Fort Collins, CO (United States)
Arizona State Univ., Tempe, AZ (United States)
Colorado School of Mines, Golden, CO (United States)

Magnesium zinc oxide (MZO, Mg_xZn_1-xO) is a leading emitter for CdTe-based solar cells due to its transparency and the ability to tune its conduction band offset with the absorber. Devices employing alloyed cadmium selenide telluride (CST, CdSe_yTe_1-y) absorbers achieved high efficiency (>19%) using MZO deposited by reactive sputtering over a broad composition range (3.68–3.92 eV, x: 0.20–0.35). Minimal differences in implied and measured open circuit voltage indicate that the contacts are well passivated and highly selective across the spectrum of MZO employed. Device performance insensitivity to MZO composition, which is not observed in CdTe devices, is attributed to the formation of an oxygenated interface layer. Se volatility creates a group VI deficiency at the interface that drives O migration from the MZO into the absorber. This introduces conductivity in the emitter not present in its as-deposited state, contributing to the exceptional performance observed. It is shown that the quality of device passivation depends on the oxidation state of the as-deposited MZO such that intelligent control and management of the reactive sputtering process is required.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Arizona State Univ., Tempe, AZ (United States)

Sponsoring Organization:: National Science Foundation (NSF); USDOE Office of Energy Efficiency and Renewable Energy (EERE)

Grant/Contract Number:: EE0008552

OSTI ID:: 1977659

Journal Information:: Solar Energy Materials and Solar Cells, Journal Name: Solar Energy Materials and Solar Cells Journal Issue: C Vol. 233; ISSN 0927-0248

Publisher:: ElsevierCopyright Statement

Country of Publication:: United States

Language:: English

References (43)

Enhanced Electron Mobility Due to Dopant-Defect Pairing in Conductive ZnMgO Ke, Yi; Lany, Stephan; Berry, Joseph J. Advanced Functional Materials, Vol. 24, Issue 19 https://doi.org/10.1002/adfm.201303204	journal	January 2014
Radiative Efficiency and Charge‐Carrier Lifetimes and Diffusion Length in Polycrystalline CdSeTe Heterostructures Kuciauskas, Darius; Moseley, John; Ščajev, Patrik physica status solidi (RRL) – Rapid Research Letters, Vol. 14, Issue 3 https://doi.org/10.1002/pssr.201900606	journal	December 2019
CdTe‐Based Solar Cells with Variations in Mg Concentration in the MgZnO Emitter Pandey, Ramesh; Munshi, Amit; Shimpi, Tushar Solar RRL, Vol. 5, Issue 7 https://doi.org/10.1002/solr.202100126	journal	April 2021
Preparation of Zn1−xMgxO films by radio frequency magnetron sputtering Minemoto, Takashi; Negami, Takayuki; Nishiwaki, Shiro Thin Solid Films, Vol. 372, Issue 1-2 https://doi.org/10.1016/S0040-6090(00)01009-9	journal	September 2000
Reactive sputter deposition of titanium dioxide Dannenberg, Rand; Greene, Phil Thin Solid Films, Vol. 360, Issue 1-2, p. 122-127 https://doi.org/10.1016/S0040-6090(99)00938-4	journal	February 2000
Valence band offset determination of CdSeTe and CdMgTe alloys with CdTe using X-ray photoemission spectroscopy LeBlanc, E. G.; Leinen, D.; Edirisooriya, M. Applied Surface Science, Vol. 529 https://doi.org/10.1016/j.apsusc.2020.147126	journal	November 2020
3D/2D passivation as a secret to success for polycrystalline thin-film solar cells McGott, Deborah L.; Muzzillo, Christopher P.; Perkins, Craig L. Joule, Vol. 5, Issue 5 https://doi.org/10.1016/j.joule.2021.03.015	journal	May 2021
Roll-over behavior in current-voltage curve introduced by an energy barrier at the front contact in thin film CdTe solar cell Li, Xun; Shen, Kai; Li, Qiang Solar Energy, Vol. 165 https://doi.org/10.1016/j.solener.2018.02.075	journal	May 2018
Band alignment of front contact layers for high-efficiency CdTe solar cells Kephart, J. M.; McCamy, J. W.; Ma, Z. Solar Energy Materials and Solar Cells, Vol. 157 https://doi.org/10.1016/j.solmat.2016.05.050	journal	December 2016
Combinatorial sputtering of Ga-doped (Zn,Mg)O for contact applications in solar cells Rajbhandari, Pravakar P.; Bikowski, André; Perkins, John D. Solar Energy Materials and Solar Cells, Vol. 159 https://doi.org/10.1016/j.solmat.2016.09.003	journal	January 2017
Effect of CdCl2 passivation treatment on microstructure and performance of CdSeTe/CdTe thin-film photovoltaic devices Munshi, Amit H.; Kephart, Jason M.; Abbas, Ali Solar Energy Materials and Solar Cells, Vol. 186 https://doi.org/10.1016/j.solmat.2018.06.016	journal	November 2018
Analysis and optimisation of the glass/TCO/MZO stack for thin film CdTe solar cells Bittau, Francesco; Potamialis, Christos; Togay, Mustafa Solar Energy Materials and Solar Cells, Vol. 187 https://doi.org/10.1016/j.solmat.2018.07.019	journal	December 2018
Stable magnesium zinc oxide by reactive Co-Sputtering for CdTe-based solar cells Samoilenko, Yegor; Yeung, Gavin; Munshi, Amit H. Solar Energy Materials and Solar Cells, Vol. 210 https://doi.org/10.1016/j.solmat.2020.110521	journal	June 2020
The role of O2 in CdSeTe thin film deposition and CdSeTe/CdTe solar cell performance Hu, Anhong; Zhou, Jie; Zhou, Peng Solar Energy Materials and Solar Cells, Vol. 214 https://doi.org/10.1016/j.solmat.2020.110595	journal	August 2020
Fundamental understanding and modeling of reactive sputtering processes Berg, S.; Nyberg, T. Thin Solid Films, Vol. 476, Issue 2 https://doi.org/10.1016/j.tsf.2004.10.051	journal	April 2005
Dynamic behaviour of the reactive sputtering process Kubart, T.; Kappertz, O.; Nyberg, T. Thin Solid Films, Vol. 515, Issue 2 https://doi.org/10.1016/j.tsf.2005.12.250	journal	October 2006
The effect of target aging on the structure formation of zinc oxide during reactive sputtering Severin, D.; Kappertz, O.; Nyberg, T. Thin Solid Films, Vol. 515, Issue 7-8 https://doi.org/10.1016/j.tsf.2006.10.130	journal	February 2007
Buffer/absorber interface recombination reduction and improvement of back-contact barrier height in CdTe solar cells Paul, Sanjoy; Swartz, Craig; Sohal, Sandeep Thin Solid Films, Vol. 685 https://doi.org/10.1016/j.tsf.2019.06.058	journal	September 2019
Degradation of Mg-doped zinc oxide buffer layers in thin film CdTe solar cells Bittau, Francesco; Jagdale, Shridhar; Potamialis, Christos Thin Solid Films, Vol. 691 https://doi.org/10.1016/j.tsf.2019.137556	journal	December 2019
Influence of the target composition on reactively sputtered titanium oxide films Kubart, T.; Jensen, J.; Nyberg, T. Vacuum, Vol. 83, Issue 10 https://doi.org/10.1016/j.vacuum.2009.03.026	journal	June 2009
Eliminating S-Kink To Maximize the Performance of MgZnO/CdTe Solar Cells Li, Deng-Bing; Song, Zhaoning; Awni, Rasha A. ACS Applied Energy Materials, Vol. 2, Issue 4 https://doi.org/10.1021/acsaem.9b00233	journal	March 2019
Two-Dimensional Cadmium Chloride Nanosheets in Cadmium Telluride Solar Cells Perkins, Craig L.; Beall, Carolyn; Reese, Matthew O. ACS Applied Materials & Interfaces, Vol. 9, Issue 24 https://doi.org/10.1021/acsami.7b03671	journal	June 2017
Thermomechanical Lift-Off and Recontacting of CdTe Solar Cells McGott, Deborah L.; Kempe, Michael D.; Glynn, Stephen ACS Applied Materials & Interfaces, Vol. 10, Issue 51 https://doi.org/10.1021/acsami.8b16476	journal	November 2018
Thin-Film Solar Cells with 19% Efficiency by Thermal Evaporation of CdSe and CdTe Ablekim, Tursun; Duenow, Joel N.; Zheng, Xin ACS Energy Letters, Vol. 5, Issue 3 https://doi.org/10.1021/acsenergylett.9b02836	journal	February 2020
Layer-by-Layer Assembly of Sintered CdSe _x Te _{1– x} Nanocrystal Solar Cells MacDonald, Brandon I.; Martucci, Alessandro; Rubanov, Sergey ACS Nano, Vol. 6, Issue 7 https://doi.org/10.1021/nn3009189	journal	June 2012
Understanding the role of selenium in defect passivation for highly efficient selenium-alloyed cadmium telluride solar cells Fiducia, Thomas A. M.; Mendis, Budhika G.; Li, Kexue Nature Energy, Vol. 4, Issue 6 https://doi.org/10.1038/s41560-019-0389-z	journal	May 2019
Exceeding 20% efficiency with in situ group V doping in polycrystalline CdTe solar cells Metzger, W. K.; Grover, S.; Lu, D. Nature Energy, Vol. 4, Issue 10 https://doi.org/10.1038/s41560-019-0446-7	journal	August 2019
Hole current impedance and electron current enhancement by back-contact barriers in CdTe thin film solar cells Pan, Jun; Gloeckler, Markus; Sites, James R. Journal of Applied Physics, Vol. 100, Issue 12 https://doi.org/10.1063/1.2400799	journal	December 2006
First-principles calculation of band offsets, optical bowings, and defects in CdS, CdSe, CdTe, and their alloys Wei, Su-Huai; Zhang, S. B.; Zunger, Alex Journal of Applied Physics, Vol. 87, Issue 3 https://doi.org/10.1063/1.372014	journal	February 2000
Emitter/absorber interface of CdTe solar cells Song, Tao; Kanevce, Ana; Sites, James R. Journal of Applied Physics, Vol. 119, Issue 23 https://doi.org/10.1063/1.4953820	journal	June 2016
The roles of carrier concentration and interface, bulk, and grain-boundary recombination for 25% efficient CdTe solar cells Kanevce, A.; Reese, M. O.; Barnes, T. M. Journal of Applied Physics, Vol. 121, Issue 21 https://doi.org/10.1063/1.4984320	journal	June 2017
Role of band alignment at the transparent front contact/emitter interface in the performance of wide bandgap thin film solar cells Liyanage, Geethika K.; Phillips, Adam B.; Heben, Michael J. APL Materials, Vol. 6, Issue 10 https://doi.org/10.1063/1.5051537	journal	October 2018
Exchange current density model for the contact-determined current-voltage behavior of solar cells Roe, Ellis T.; Egelhofer, Kira E.; Lonergan, Mark C. Journal of Applied Physics, Vol. 125, Issue 22 https://doi.org/10.1063/1.5090519	journal	June 2019
Recombination and bandgap engineering in CdSeTe/CdTe solar cells Zheng, X.; Kuciauskas, D.; Moseley, J. APL Materials, Vol. 7, Issue 7 https://doi.org/10.1063/1.5098459	journal	July 2019
Roles of bandgrading, lifetime, band alignment, and carrier concentration in high-efficiency CdSeTe solar cells Zheng, X.; Colegrove, E.; Duenow, J. N. Journal of Applied Physics, Vol. 128, Issue 5 https://doi.org/10.1063/5.0013726	journal	August 2020
Energy band alignment in chalcogenide thin film solar cells from photoelectron spectroscopy Klein, Andreas Journal of Physics: Condensed Matter, Vol. 27, Issue 13 https://doi.org/10.1088/0953-8984/27/13/134201	journal	March 2015
Polycrystalline CdSeTe/CdTe Absorber Cells With 28 mA/cm ² Short-Circuit Current Munshi, Amit H.; Kephart, Jason; Abbas, Ali IEEE Journal of Photovoltaics, Vol. 8, Issue 1 https://doi.org/10.1109/JPHOTOV.2017.2775139	journal	January 2018
Sputter-Deposited Oxides for Interface Passivation of CdTe Photovoltaics Kephart, Jason M.; Kindvall, Anna; Williams, Desiree IEEE Journal of Photovoltaics, Vol. 8, Issue 2 https://doi.org/10.1109/JPHOTOV.2017.2787021	journal	March 2018
Tailoring MgZnO/CdSeTe Interfaces for Photovoltaics Ablekim, Tursun; Perkins, Craig; Zheng, Xin IEEE Journal of Photovoltaics, Vol. 9, Issue 3 https://doi.org/10.1109/JPHOTOV.2018.2877982	journal	May 2019
The use of nitrogen flow as a deposition rate control in reactive sputtering Berg, S.; Larsson, T.; Blom, H‐O. Journal of Vacuum Science & Technology A: Vacuum, Surfaces, and Films, Vol. 4, Issue 3 https://doi.org/10.1116/1.573855	journal	May 1986
Modeling of reactive sputtering of compound materials Berg, S.; Blom, H‐O.; Larsson, T. Journal of Vacuum Science & Technology A: Vacuum, Surfaces, and Films, Vol. 5, Issue 2, p. 202-207 https://doi.org/10.1116/1.574104	journal	March 1987
Controlling conduction band alignment and carrier concentration in gallium-doped magnesium zinc oxide by reactive cosputtering Yeung, Gavin; Wolden, Colin A. Journal of Vacuum Science & Technology A, Vol. 39, Issue 2 https://doi.org/10.1116/6.0000784	journal	March 2021
Influence of the Physical, Structural and Chemical Properties on the Photoresponse Property of Magnetron Sputtered TiO₂ for the Application of Water Splitting Rahman, M.; MacElroy, J. M. D.; Dowling, D. P. Journal of Nanoscience and Nanotechnology, Vol. 11, Issue 10 https://doi.org/10.1166/jnn.2011.3458	journal	October 2011

Similar Records

Transparent MgO for Back-Contact Passivation of CdTe-Based Solar Cells

Conference · Thu Aug 26 04:00:00 UTC 2021 · OSTI ID:1823782

Pandey, Ramesh; Shah, Akash; Munshi, Amit; +4 more

Buffer/absorber interface recombination reduction and improvement of back-contact barrier height in CdTe solar cells

Journal Article · Tue Jul 02 00:00:00 UTC 2019 · Thin Solid Films · OSTI ID:1579310

Paul, Sanjoy; Swartz, Craig; Sohal, Sandeep; +6 more

Stable magnesium zinc oxide by reactive Co-Sputtering for CdTe-based solar cells

Journal Article · Fri Mar 27 00:00:00 UTC 2020 · Solar Energy Materials and Solar Cells · OSTI ID:1659933

Samoilenko, Yegor; Yeung, Gavin; Munshi, Amit H.; +8 more

Related Subjects

36 MATERIALS SCIENCE
CdSeTe
Energy & fuels
MgZnO
implied voltage
materials science
passivation
physics
reactive sputtering

Title: Robust passivation of CdSeTe based solar cells using reactively sputtered magnesium zinc oxide

Citation Formats

References (43)

Similar Records

Related Subjects