Investigation of long-term light stability of negative charge injected into oxide-nitride-oxide passivation stack of crystalline silicon solar cells
Abstract
A negatively charged oxide-nitride-oxide stack for field-effect passivation of crystalline silicon solar cells is discussed. The negative charge was injected into the stack by a plasma charge injection technology. Charge stability was studied by exposing samples to AM1.5 simulation visible light and full-spectrum light at temperatures ranging from 55 to 78 °C for up to 300 h. Charge injection and loss were quantified based on shifts in the flatband voltage of capacitance–voltage curves measured with a mercury probe. The most probable mechanism of charge loss was found to be diffusion of negative charged hydrogen atoms through nitride and bottom oxide. The optimum recipe for each layer of the stack was investigated to minimize the loss of injected charge. The flatband voltage decay of the optimized stack was found to fit a power-law trend, suggesting the dispersive transport of hydrogen atoms with a dispersion parameter of ~0.06–0.07. The optimized stack is projected to maintain a negative charge density of about 3.6 × 1012 cm–2 or more after 25 years of field operation in an environment such as Arizona, which would be sufficient for field-effect passivation under one-sun illumination. Furthermore, the high stability of the negative injected charge makes the plasma chargingmore »
- Authors:
-
- Inert Plasma Charging LLC, Chandler, AZ (United States)
- Georgia Institute of Technology, Atlanta, GA (United States)
- Publication Date:
- Research Org.:
- Inert Plasma Charging LLC, Chandler, AZ (United States)
- Sponsoring Org.:
- USDOE Office of Energy Efficiency and Renewable Energy (EERE), Renewable Power Office. Solar Energy Technologies Office
- OSTI Identifier:
- 1901728
- Alternate Identifier(s):
- OSTI ID: 1901447; OSTI ID: 2283137
- Grant/Contract Number:
- EE0008566
- Resource Type:
- Accepted Manuscript
- Journal Name:
- Journal of Applied Physics
- Additional Journal Information:
- Journal Volume: 132; Journal Issue: 21; Journal ID: ISSN 0021-8979
- Publisher:
- American Institute of Physics (AIP)
- Country of Publication:
- United States
- Language:
- English
- Subject:
- 14 SOLAR ENERGY; 30 DIRECT ENERGY CONVERSION; 42 ENGINEERING; silicon solar cell; silicon nitride; oxide-nitride-oxide passivation stack; charge injection; charge stability; light stability; dispersive transport; hydrogen diffusion; chemical vapor deposition; capacitance voltage profiling; solar cells; optical absorption; hydrogen; plasma applications; passivation; charge dynamics; nitrides; oxides
Citation Formats
Chen, Christopher, Hwang, Jeong-Mo, Ok, Young-Woo, Choi, Wook-Jin, Upadhyaya, Vijaykumar, Rounsaville, Brian, and Rohatgi, Ajeet. Investigation of long-term light stability of negative charge injected into oxide-nitride-oxide passivation stack of crystalline silicon solar cells. United States: N. p., 2022.
Web. doi:10.1063/5.0111681.
Chen, Christopher, Hwang, Jeong-Mo, Ok, Young-Woo, Choi, Wook-Jin, Upadhyaya, Vijaykumar, Rounsaville, Brian, & Rohatgi, Ajeet. Investigation of long-term light stability of negative charge injected into oxide-nitride-oxide passivation stack of crystalline silicon solar cells. United States. https://doi.org/10.1063/5.0111681
Chen, Christopher, Hwang, Jeong-Mo, Ok, Young-Woo, Choi, Wook-Jin, Upadhyaya, Vijaykumar, Rounsaville, Brian, and Rohatgi, Ajeet. Thu .
"Investigation of long-term light stability of negative charge injected into oxide-nitride-oxide passivation stack of crystalline silicon solar cells". United States. https://doi.org/10.1063/5.0111681. https://www.osti.gov/servlets/purl/1901728.
@article{osti_1901728,
title = {Investigation of long-term light stability of negative charge injected into oxide-nitride-oxide passivation stack of crystalline silicon solar cells},
author = {Chen, Christopher and Hwang, Jeong-Mo and Ok, Young-Woo and Choi, Wook-Jin and Upadhyaya, Vijaykumar and Rounsaville, Brian and Rohatgi, Ajeet},
abstractNote = {A negatively charged oxide-nitride-oxide stack for field-effect passivation of crystalline silicon solar cells is discussed. The negative charge was injected into the stack by a plasma charge injection technology. Charge stability was studied by exposing samples to AM1.5 simulation visible light and full-spectrum light at temperatures ranging from 55 to 78 °C for up to 300 h. Charge injection and loss were quantified based on shifts in the flatband voltage of capacitance–voltage curves measured with a mercury probe. The most probable mechanism of charge loss was found to be diffusion of negative charged hydrogen atoms through nitride and bottom oxide. The optimum recipe for each layer of the stack was investigated to minimize the loss of injected charge. The flatband voltage decay of the optimized stack was found to fit a power-law trend, suggesting the dispersive transport of hydrogen atoms with a dispersion parameter of ~0.06–0.07. The optimized stack is projected to maintain a negative charge density of about 3.6 × 1012 cm–2 or more after 25 years of field operation in an environment such as Arizona, which would be sufficient for field-effect passivation under one-sun illumination. Furthermore, the high stability of the negative injected charge makes the plasma charging technology a safer and lower cost alternative to Al2O3-passivation technology commonly used to passivate p-type surfaces.},
doi = {10.1063/5.0111681},
journal = {Journal of Applied Physics},
number = 21,
volume = 132,
place = {United States},
year = {Thu Dec 01 00:00:00 EST 2022},
month = {Thu Dec 01 00:00:00 EST 2022}
}
Works referenced in this record:
Analysis of the negative charges injected into a SiO
2
/SiN
x
stack using plasma charging technology for field‐effect passivation on a boron‐doped silicon surface
journal, October 2020
- Min, Kwan Hong; Hwang, Jeong‐Mo; Cho, Eunwan
- Progress in Photovoltaics: Research and Applications, Vol. 29, Issue 1
Atomic‐Layer‐Deposited Al 2 O 3 as Effective Barrier against the Diffusion of Hydrogen from SiN x :H Layers into Crystalline Silicon during Rapid Thermal Annealing
journal, October 2020
- Helmich, Lailah; Walter, Dominic C.; Bredemeier, Dennis
- physica status solidi (RRL) – Rapid Research Letters, Vol. 14, Issue 12
Reduced hydrogen diffusion in strained amorphous SiO2: understanding ageing in MOSFET devices
journal, January 2016
- Sheikholeslam, S. Arash; Manzano, Hegoi; Grecu, Cristian
- Journal of Materials Chemistry C, Vol. 4, Issue 34
The dispersive diffusion of hydrogen in undoped a—Si:H
journal, April 1991
- Tang, X. -M.; Weber, J.; Baer, Y.
- Physica B: Condensed Matter, Vol. 170, Issue 1-4
Low-Temperature Surface Passivation of Silicon for Solar Cells
journal, January 1989
- Hezel, R.
- Journal of The Electrochemical Society, Vol. 136, Issue 2
Microscopic origin of the light-induced defects in hydrogenated nitrogen-rich amorphous silicon nitride films
journal, January 1991
- Kanicki, J.; Warren, W. L.; Seager, C. H.
- Journal of Non-Crystalline Solids, Vol. 137-138
Ultralow surface recombination of c-Si substrates passivated by plasma-assisted atomic layer deposited Al2O3
journal, July 2006
- Hoex, B.; Heil, S. B. S.; Langereis, E.
- Applied Physics Letters, Vol. 89, Issue 4
Simulating the diffusion of hydrogen in amorphous silicates: A ‘jumping’ migration process and its implications for solar wind implanted lunar volatiles
journal, June 2022
- Morrissey, Liam S.; Pratt, D.; Farrell, W. M.
- Icarus, Vol. 379
Experimental evidence of parasitic shunting in silicon nitride rear surface passivated solar cells
journal, January 2002
- Dauwe, Stefan; Mittelstädt, Lutz; Metz, Axel
- Progress in Photovoltaics: Research and Applications, Vol. 10, Issue 4, p. 271-278
Configurational statistics in a - alloys: A quantitative bonding analysis
journal, October 1988
- Bustarret, E.; Bensouda, M.; Habrard, M. C.
- Physical Review B, Vol. 38, Issue 12
Plasma charge injection technology and its application to c-Si solar cells for field-effect passivation
journal, May 2019
- Hwang, Jeong-Mo
- Journal of Applied Physics, Vol. 125, Issue 17
Hydrogen ion diffusion coefficient of a hydrogenated amorphous silicon thin film
journal, February 2003
- Yu, George C.
- Journal of Materials Chemistry, Vol. 13, Issue 4
Dispersive diffusion of hydrogen ina-Si:H: Influence of the film deposition temperature
journal, April 1990
- Tang, X. -M.; Weber, J.; Baer, Y.
- Physical Review B, Vol. 41, Issue 11
Dispersive Transport and Negative Bias Temperature Instability: Boundary Conditions, Initial Conditions, and Transport Models
journal, March 2008
- Grasser, T.; Gos, W.; Kaczer, B.
- IEEE Transactions on Device and Materials Reliability, Vol. 8, Issue 1
Nature of long-range atomic H motion ina-Si:H
journal, April 1989
- Shinar, J.; Shinar, R.; Mitra, S.
- Physical Review Letters, Vol. 62, Issue 17
Defects and hydrogen in amorphous silicon nitride
journal, February 1994
- Robertson, J.
- Philosophical Magazine B, Vol. 69, Issue 2
Hydrogen diffusion coefficient of silicon nitride thin films
journal, November 2002
- Yu, George C.; Yen, S. K.
- Applied Surface Science, Vol. 201, Issue 1-4
Spectra-Dependent Stability of the Passivation Quality of Al2O3/c-Si Interfaces
journal, January 2018
- Veith-Wolf, Boris; Witteck, Robert; Morlier, Arnaud
- IEEE Journal of Photovoltaics, Vol. 8, Issue 1
Stretched-exponential relaxation arising from dispersive diffusion of hydrogen in amorphous silicon
journal, August 1987
- Kakalios, J.; Street, R. A.; Jackson, W. B.
- Physical Review Letters, Vol. 59, Issue 9