Trailing edge devices to improve performance and increase lifetime of wind-electric water pumping systems
- USDA-Agricultural Research Service, Bushland, TX (United States)
Trailing edge flaps were applied to the blades of a 10 kW wind turbine used for water pumping to try to improve the performance and decrease the structural fatigue on the wind turbine. Most small wind turbines (10 kW and below) use furling (rotor turns out of wind similar to a mechanical windmill) to protect the wind turbine from overspeed during high winds. Some small wind turbines, however, do not furl soon enough to keep the wind turbine from being off line part of the time in moderately high wind speeds (10 - 16 m/s). As a result, the load is disconnected and no water is pumped at moderately high wind speeds. When the turbine is offline, the frequency increases rapidly often causing excessive vibration of the wind turbine and tower components. The furling wind speed could possibly be decreased by increasing the offset between the tower centerline and the rotor centerline, but would be a major and potentially expensive retrofit. Trailing edge flaps (TEF) were used as a quick inexpensive method to try to reduce the furling wind speed and increase the on time by reducing the rotor RPM. One TEF configuration improved the water pumping performance at moderately high wind speeds, but degraded the pumping performance at low wind speeds which resulted in little change in daily water volume. The other TEF configuration differed very little from the no flap configuration. Both TEF configurations however, reduced the rotor RPM in high wind conditions. The TEF, did not reduce the rotor RPM by lowering the furling wind speed as hoped, but apparently did so by increasing the drag which also reduced the volume of water pumped at the lower wind speeds. 6 refs., 9 figs.
- Research Organization:
- USDOE, Washington, DC (United States); National Renewable Energy Lab., Golden, CO (United States)
- OSTI ID:
- 447480
- Report Number(s):
- CONF-960630--; ON: DE97002833
- Country of Publication:
- United States
- Language:
- English
Similar Records
Soft-Stall Control versus Furling Control for Small Wind Turbine Power Regulation
An evaluation of several wind turbine trailing-edge aerodynamic brakes