Effects of grit roughness and pitch oscillations on the NACA 4415 airfoil

Technical Report · Mon Jul 01 04:00:00 EDT 1996

DOI:https://doi.org/10.2172/266691· OSTI ID:266691

Hoffmann, M J; Reuss Ramsay, R; Gregorek, G M ^[1]

---

1. Ohio State Univ., Columbus, OH (United States)

A NACA 4415 airfoil model was tested in The Ohio State University Aeronautical and Astronautical Research Laboratory 3 x 5 subsonic wind tunnel under steady state and unsteady conditions. The test defined baseline conditions for steady state angles of attack from {minus}10{degree} to +40{degree} and examined unsteady behavior by oscillating the model about its pitch axis for three mean angles, three frequencies, and two amplitudes. For all cases, Reynolds numbers of 0.75, 1, 1.25, and 1.5 million were used. In addition, these were repeated after the application of leading edge grit roughness (LEGR) to determine contamination effects on the airfoil performance. Steady state results of the NACA 4415 testing at Reynolds number of 1.25 million showed a baseline maximum lift coefficient of 1.30 at 12.3{degree} angle of attack. The application of LEGR reduced the maximum lift coefficient by 20% and increased the 0.0090 minimum drag coefficient value by 62%. The zero lift pitching moment of {minus}0.0967 showed a 13% reduction in magnitude to {minus}0.0842 with LEGR applied. Data were also obtained for two pitch oscillation amplitudes: {+-}5.5{degree} and {+-}10{degree}. The larger amplitude consistently gave a higher maximum lift coefficient than the smaller amplitude, and both unsteady maximum lift coefficients were greater than the steady state values. Stall is delayed on the airfoil while the angle of attack is increasing, thereby causing an increase in maximum lift coefficient. A hysteresis behavior was exhibited for all the unsteady test cases. The hysteresis loops were larger for the higher reduced frequencies and for the larger amplitude oscillations. As in the steady case, the effect of LEGR in the unsteady case was to reduce the lift coefficient at high angles of attack. In addition, with LEGR, the hysteresis behavior persisted into lower angles of attack than for the clean case.

• Research Organization: National Renewable Energy Lab., Golden, CO (United States); Ohio State Univ., Columbus, OH (United States)
• Sponsoring Organization: USDOE, Washington, DC (United States)
• DOE Contract Number: AC36-83CH10093
• OSTI ID: 266691
• Report Number(s): NREL/TP--442-7815; ON: DE96007943; CNN: Contract XF-1-11009-3
• Country of Publication: United States
• Language: English

Related Subjects

17 WIND ENERGY
AIRFOILS
FUNCTIONAL MODELS
HORIZONTAL AXIS TURBINES
PERFORMANCE TESTING
ROUGHNESS
TURBINE BLADES