Pretreatment of Bituminous Coal By-Products for the Hydrometallurgical Extraction of Rare Earth Elements

Gupta, Tushar; Nawab, Ahmad; Honaker, Rick

doi:10.3390/min13050614

Pretreatment of Bituminous Coal By-Products for the Hydrometallurgical Extraction of Rare Earth Elements

Journal Article · Fri Apr 28 00:00:00 EDT 2023 · Minerals

DOI:https://doi.org/10.3390/min13050614· OSTI ID:2418154

^[1]; ^[2]; ^[2]

MP Materials Mountain Pass Mine, CA (United States); Univ. of Kentucky, Lexington, KY (United States)
Univ. of Kentucky, Lexington, KY (United States)

Low-temperature plasma (LTP) oxidation has been widely used to study the mineralogy of the mineral matter existing in coal sources. The current study investigated the potential of LTP oxidation as a pre-treatment method to improve rare earth element (REE) leachability from coal and its by-products. Representative density-fractionated samples of Baker and Fire Clay coarse refuse seam materials were ground to a top size of 180 µm and subjected to low-temperature plasma oxidation. Subsequently, the treated samples were leached at 1% w/v solids concentration and 75 °C for 5 h using (i) de-ionized (DI) water, (ii) 0.1 mol/L of ammonium sulfate, and (iii) 1.2 mol/L of sulfuric acid. It was determined that LTP treatment improved REE leaching characteristics, especially the leaching of heavy REEs (HREE), existing in the lighter density fractions of the Baker seam coarse refuse material. For instance, the HREE recovery for the 1.6 specific gravity (SG) float fraction increased from 8% to 33% using 0.1 mol/L of ammonium sulfate solution after 32 h of LTP treatment. This finding indicated that HREEs associated with the organic matter were released by the LTP treatment and adsorbed onto the surfaces of highly negative charged mineral matter and was exchanged with ammonium to allow their recovery. Similarly, when using 1.2 mol/L of sulfuric acid, the HREE recovery increased from 23% to 53% for the 1.6 SG float fraction. Interestingly, LTP oxidation did not provide significant improvement in REE recovery from the 2.2 sink density fractions, which was likely due to its lower organic content. No significant benefits were observed when treating the Fire Clay coarse refuse material, which was likely due to the lack of organic affinity and the difficult-to-leach REE minerals associated with the coal source such as monazite, xenotime, and zircon. Conversely, high-temperature oxidation within a temperature range of 600–750 °C significantly improved REE leaching characteristics for both coal sources. Improvement in REE recovery was due to decarbonization of the material, clay dehydroxylation and subsequent conversion of liberated REE-bearing minerals into a more leachable form. However, increasing the temperature above 800 °C decreased REE recovery due to the conversion of meta-kaolinite into mullite, which is chemically stable.

View Accepted Manuscript (DOE)

Research Organization:: Univ. of Kentucky, Lexington, KY (United States)

Sponsoring Organization:: USDOE Office of Fossil Energy and Carbon Management (FECM)

Grant/Contract Number:: FE0031525

OSTI ID:: 2418154

Journal Information:: Minerals, Journal Name: Minerals Journal Issue: 5 Vol. 13; ISSN 2075-163X

Publisher:: MDPICopyright Statement

Country of Publication:: United States

Language:: English

References (21)

Hydrometallurgical Recovery of Rare Earth Elements from Mine Tailings and WEEE Peelman, S.; Kooijman, D.; Sietsma, J. Journal of Sustainable Metallurgy, Vol. 4, Issue 3 https://doi.org/10.1007/s40831-018-0178-0	journal	May 2018
Determination of the mineral-matter contents of coals by low-temperature ashing Miller, Robert N.; Yarzab, Richard F.; Given, Peter H. Fuel, Vol. 58, Issue 1 https://doi.org/10.1016/0016-2361(79)90044-9	journal	January 1979
Glow discharge excited low temperature ashing Adolphi, Peter; Stör, Manfred Fuel, Vol. 64, Issue 2 https://doi.org/10.1016/0016-2361(85)90208-X	journal	February 1985
Lanthanide, yttrium, and zirconium anomalies in the Fire Clay coal bed, Eastern Kentucky Hower, James C.; Ruppert, Leslie F.; Eble, Cortland F. International Journal of Coal Geology, Vol. 39, Issue 1-3 https://doi.org/10.1016/S0166-5162(98)00043-3	journal	March 1999
Decomposition of bastnasite and monazite mixed rare earth minerals calcined by alkali liquid Xu, Yanhui; Liu, Haijiao; Meng, Zhijun Journal of Rare Earths, Vol. 30, Issue 2 https://doi.org/10.1016/S1002-0721(12)60014-3	journal	February 2012
Leaching kinetics of bastnaesite concentrate in HCl solution Bian, Xue; Yin, Shao-hua; Luo, Yao Transactions of Nonferrous Metals Society of China, Vol. 21, Issue 10 https://doi.org/10.1016/S1003-6326(11)61012-1	journal	October 2011
Mineralogy and geochemistry of boehmite-rich coals: New insights from the Haerwusu Surface Mine, Jungar Coalfield, Inner Mongolia, China Dai, Shifeng; Li, Dan; Chou, Chen-Lin International Journal of Coal Geology, Vol. 74, Issue 3-4 https://doi.org/10.1016/j.coal.2008.01.001	journal	May 2008
Coal deposits as potential alternative sources for lanthanides and yttrium Seredin, Vladimir V.; Dai, Shifeng International Journal of Coal Geology, Vol. 94 https://doi.org/10.1016/j.coal.2011.11.001	journal	May 2012
Rare earth minerals in a “no tonstein” section of the Dean (Fire Clay) coal, Knox County, Kentucky Hower, James C.; Berti, Debora; Hochella, Michael F. International Journal of Coal Geology, Vol. 193 https://doi.org/10.1016/j.coal.2018.05.001	journal	June 2018
Association characteristic study and preliminary recovery investigation of rare earth elements from Fire Clay seam coal middlings Zhang, Wencai; Yang, Xinbo; Honaker, Rick Q. Fuel, Vol. 215 https://doi.org/10.1016/j.fuel.2017.11.075	journal	March 2018
Characterization and recovery of rare earth elements and other critical metals (Co, Cr, Li, Mn, Sr, and V) from the calcination products of a coal refuse sample Zhang, Wencai; Honaker, Rick Fuel, Vol. 267 https://doi.org/10.1016/j.fuel.2020.117236	journal	May 2020
Rare earth elements (REEs) recovery from coal waste of the Western Kentucky No. 13 and Fire Clay Seams. Part I: Mineralogical characterization using SEM-EDS and TEM-EDS Ji, Bin; Li, Qi; Zhang, Wencai Fuel, Vol. 307 https://doi.org/10.1016/j.fuel.2021.121854	journal	January 2022
Rare earth elements (REEs) recovery from coal waste of the Western Kentucky No. 13 and Fire Clay seams. Part II: Re-investigation on the effect of calcination Ji, Bin; Li, Qi; Tang, Honghu Fuel, Vol. 315 https://doi.org/10.1016/j.fuel.2022.123145	journal	May 2022
Recovery of rare earth elements adsorbed on clay minerals: I. Desorption mechanism Moldoveanu, Georgiana A.; Papangelakis, Vladimiros G. Hydrometallurgy, Vol. 117-118 https://doi.org/10.1016/j.hydromet.2012.02.007	journal	April 2012
Recovery of yttrium and lanthanides from sulfate solutions with high concentration of iron and low rare earth content Beltrami, Denis; Deblonde, Gauthier J. -P.; Bélair, Sarah Hydrometallurgy, Vol. 157 https://doi.org/10.1016/j.hydromet.2015.07.015	journal	October 2015
Thermal plasma technology for the treatment of wastes: A critical review Gomez, E.; Rani, D. Amutha; Cheeseman, C. R. Journal of Hazardous Materials, Vol. 161, Issue 2-3 https://doi.org/10.1016/j.jhazmat.2008.04.017	journal	January 2009
Leaching of rare Earth elements from an Illinois basin coal source Yang, X.; Werner, J.; Honaker, R. Q. Journal of Rare Earths, Vol. 37, Issue 3 https://doi.org/10.1016/j.jre.2018.07.003	journal	March 2019
An acid baking approach to enhance heavy rare earth recovery from bituminous coal-based sources Nawab, Ahmad; Yang, Xinbo; Honaker, Rick Minerals Engineering, Vol. 184 https://doi.org/10.1016/j.mineng.2022.107610	journal	June 2022
Use of Electrically Excited Oxygen for the Low Temperature Decomposition of Organic Substances. Gleit, C. E.; Holland, W. D. Analytical Chemistry, Vol. 34, Issue 11 https://doi.org/10.1021/ac60191a031	journal	October 1962
A Review of the Occurrence and Promising Recovery Methods of Rare Earth Elements from Coal and Coal By-Products Zhang, Wencai; Rezaee, Mohammad; Bhagavatula, Abhijit International Journal of Coal Preparation and Utilization, Vol. 35, Issue 6 https://doi.org/10.1080/19392699.2015.1033097	journal	July 2015
A Comprehensive Review of Rare Earth Elements Recovery from Coal-Related Materials Zhang, Wencai; Noble, Aaron; Yang, Xinbo Minerals, Vol. 10, Issue 5 https://doi.org/10.3390/min10050451	journal	May 2020

Similar Records

Low-Temperature Plasma Treatment for Enhanced Recovery of Highly Valued Critical REEs from Coal (Final Report)

Technical Report · Mon Jan 20 23:00:00 EST 2020 · OSTI ID:1592980

Low-Temperature Plasma Treatment for Enhanced Recovery of Highly Valued Critical REEs from Coal (Final Technical Report)

Technical Report · Mon Jan 20 23:00:00 EST 2020 · OSTI ID:1778177

Removal of Iron from Pyrite-Rich Coal Refuse by Calcination and Magnetic Separation for Hydrometallurgical Extraction of Rare Earth Elements

Journal Article · Sat Feb 25 19:00:00 EST 2023 · Minerals · OSTI ID:2418216

Related Subjects

58 GEOSCIENCES
Geochemistry & Geophysics
Mineralogy
Mining & Mineral Processing
high-temperature oxidation
leaching
low-temperature plasma oxidation
rare earth elements
roasting

Pretreatment of Bituminous Coal By-Products for the Hydrometallurgical Extraction of Rare Earth Elements

Citation Formats

References (21)

Similar Records

Related Subjects