Skip to main content
OSTI.GOVU.S. Department of Energy Office of Scientific and Technical Information
U.S. Department of Energy
Office of Scientific and Technical Information
 

Optimization of operational strategies for rich gas enhanced oil recovery based on a pilot test in the Bakken tight oil reservoir

Journal Article · · Petroleum Science (Online)
 [1];  [2];  [2];  [2];  [2];  [2];  [2]
  1. University of North Dakota, Grand Forks, ND (United States); Univ. of North Dakota, Grand Forks, ND (United States). Energy and Environmental Research Center
  2. University of North Dakota, Grand Forks, ND (United States)
+ Show Author Affiliations
Horizontal well drilling and multistage hydraulic fracturing have been demonstrated as effective approaches for stimulating oil production in the Bakken tight oil reservoir. However, after multiple years of production, primary oil recovery in the Bakken is generally less than 10% of the estimated original oil in place. Gas huff ‘n’ puff (HnP) has been tested in the Bakken Formation as an enhanced oil recovery (EOR) method; however, most field pilot test results showed no significant incremental oil production. One of the factors affecting HnP EOR performance is premature gas breakthrough, which is one of the most critical issues observed in the field because of the presence of interwell fractures. Consequently, injected gas rapidly reaches adjacent production wells without contacting reservoir rock and increasing oil recovery. Proper conformance control is therefore needed to avoid early gas breakthrough and improve EOR performance. In this study, a rich gas EOR pilot in the Bakken was carefully analyzed to collect the essential reservoir and operational data. A simulation model with 16 wells was then developed to reproduce the production history and predict the EOR performance with and without conformance control. EOR operational strategies, including single- and multiple-well HnP, with different gas injection constraints were investigated. The simulation results of single-well HnP without conformance control showed that a rich gas injection rate of at least 10 MMscfd was needed to yield meaningful incremental oil production. The strategy of conformance control via water injection could significantly improve oil production in the HnP well, but injecting an excessive amount of water also leads to water breakthrough and loss of oil production in the offset wells. By analyzing the production performance of the wells individually, the arrangement of wells was optimized for multiple-well HnP EOR. The multiwell results showed that rich gas EOR could improve oil production up to 7.4% by employing conformance control strategies. Furthermore, replacing rich gas with propane as the injection gas could result in 14% of incremental oil production.
Research Organization:
University of North Dakota, Grand Forks, ND (United States)
Sponsoring Organization:
USDOE
Grant/Contract Number:
FE0024233
OSTI ID:
2370085
Journal Information:
Petroleum Science (Online), Journal Name: Petroleum Science (Online) Journal Issue: 5 Vol. 20; ISSN 1995-8226
Publisher:
ElsevierCopyright Statement
Country of Publication:
United States
Language:
English

References (30)

A new dual-porosity/dual-permeability model with non-Darcian flow through fractures journal May 1997
Advancing CO2 enhanced oil recovery and storage in unconventional oil play—Experimental studies on Bakken shales journal December 2017
A diffuse layer model for hydrocarbon mass transfer between pores and organic matter for supercritical CO2 injection and sequestration in shale journal February 2021
Laboratory Characterization and Modeling to Examine CO2 Storage and Enhanced Oil Recovery in an Unconventional Tight Oil Formation journal July 2017
Evaluation of recycle gas injection on CO2 enhanced oil recovery and associated storage performance journal August 2018
Effects of gas relative permeability hysteresis and solubility on associated CO2 storage performance journal August 2018
Laboratory determination of oil draining CO2 hysteresis effects during multiple floods of a conventional clastic oil reservoir journal November 2018
Implementing adaptive scaling and dynamic well-tie for quantitative 4-D seismic evaluation of a reservoir subjected to CO2 enhanced oil recovery and associated storage journal November 2018
Joint impedance and facies inversion of time-lapse seismic data for improving monitoring of CO2 incidentally stored from CO2 EOR journal December 2021
Extension of the Gas Research Institute (GRI) method to measure the permeability of tight rocks journal July 2021
Sensitivity analysis of hydraulic fracture geometry in shale gas reservoirs journal January 2014
A comprehensive review on chemically enhanced water alternating gas/CO2 (CEWAG) injection for enhanced oil recovery journal August 2017
An integrated approach of measuring permeability of naturally fractured shale journal March 2020
Coupling of fracture model with reservoir simulation to simulate shale gas production with complex fractures and nanopores journal October 2020
Selection of hydrocarbon gas for huff-n-puff IOR in shale oil reservoirs journal December 2020
Sustainability lessons from shale development in the United States for Mexico and other emerging unconventional oil and gas developers journal February 2018
Experimental Determinations of Minimum Miscibility Pressures Using Hydrocarbon Gases and CO 2 for Crude Oils from the Bakken and Cut Bank Oil Reservoirs journal April 2020
Comparison of CO2 and Produced Gas Hydrocarbons to Recover Crude Oil from Williston Basin Shale and Mudrock Cores at 10.3, 17.2, and 34.5 MPa and 110 °C journal March 2021
Investigating Enhanced Oil Recovery in Unconventional Reservoirs Based on Field Case Review, Laboratory, and Simulation Studies journal November 2022
Rapid and Simple Capillary-Rise/Vanishing Interfacial Tension Method To Determine Crude Oil Minimum Miscibility Pressure: Pure and Mixed CO 2 , Methane, and Ethane journal July 2016
Lab and Reservoir Study of Produced Hydrocarbon Molecular Weight Selectivity during CO 2 Enhanced Oil Recovery journal July 2018
A Literature Review of CO 2 , Natural Gas, and Water-Based Fluids for Enhanced Oil Recovery in Unconventional Reservoirs journal March 2020
Molecular Simulation Study on the Volume Swelling and the Viscosity Reduction of n-Alkane/CO2 Systems journal May 2019
Hierarchical modeling of flow in naturally fractured formations with multiple length scales journal March 2001
A Novel Method to Enhance Oil Recovery by Inter-Fracture Injection and Production Through the Same Multi-Fractured Horizontal Well journal July 2021
Efficient Field-Scale Simulation of Black Oil in a Naturally Fractured Reservoir Through Discrete Fracture Networks and Homogenized Media journal August 2008
Improving Oil Recovery by Use of Carbon Dioxide in the Bakken Unconventional System: A Laboratory Investigation journal December 2016
Discrete-Fracture Modeling of Complex Hydraulic-Fracture Geometries in Reservoir Simulators journal August 2016
Applying Reservoir Simulation and Artificial Intelligence Algorithms to Optimize Fracture Characterization and CO2 Enhanced Oil Recovery in Unconventional Reservoirs: A Case Study in the Wolfcamp Formation journal November 2022
Enhanced Oil Recovery: An Update Review journal August 2010

Figures / Tables (37)

Fig. 1(p. 3)figure Fig. 1
Fig. 2(p. 4)figure Fig. 2
Table 1(p. 4)table Table 1
Table 2(p. 4)table Table 2
Fig. 3(p. 5)figure Fig. 3
Fig. 4(p. 5)figure Fig. 4
Fig. 5(p. 5)figure Fig. 5
Fig. 6(p. 6)figure Fig. 6
Fig. 7(p. 7)figure Fig. 7
Fig. 8(p. 7)figure Fig. 8
Table 3(p. 7)table Table 3
Fig. 9(p. 8)figure Fig. 9
Table 4(p. 8)table Table 4
Table 5(p. 8)table Table 5
Table 6(p. 8)table Table 6
Fig. 10(p. 9)figure Fig. 10
Fig. 11(p. 9)figure Fig. 11
Fig. 12(p. 10)figure Fig. 12
Fig. 13(p. 10)figure Fig. 13
Fig. 14(p. 11)figure Fig. 14
Fig. 15(p. 11)figure Fig. 15
Table 7(p. 11)table Table 7
Table 8(p. 11)table Table 8
Fig. 16(p. 12)figure Fig. 16
Fig. 17(p. 12)figure Fig. 17
Fig. 18(p. 12)figure Fig. 18
Fig. 19(p. 13)figure Fig. 19
Fig. 20(p. 13)figure Fig. 20
Fig. 21(p. 13)figure Fig. 21
Fig. 22(p. 14)figure Fig. 22
Fig. 23(p. 14)figure Fig. 23
Fig. 24(p. 15)figure Fig. 24
Fig. 25(p. 15)figure Fig. 25
Table 10(p. 15)table Table 10
Table 9(p. 15)table Table 9
Fig. 26(p. 16)figure Fig. 26
Table 11(p. 16)table Table 11

Similar Records

Optimizing conformance control for gas injection EOR in unconventional reservoirs
Journal Article · Wed Aug 31 20:00:00 EDT 2022 · Fuel · OSTI ID:1977139
Findings on Subtask 3.1 - Bakken Rich Gas Enhanced Oil Recovery Project
Other · Thu Jan 27 23:00:00 EST 2022 · OSTI ID:1842463
Progress of Gas Injection EOR Surveillance in the Bakken Unconventional Play—Technical Review and Machine Learning Study
Journal Article · Thu Aug 22 20:00:00 EDT 2024 · Energies · OSTI ID:2580304

Related Subjects

02 PETROLEUM
58 GEOSCIENCES
Bakken tight oil reservoir
Conformance control
EOR strategies
Embedded discrete fracture model
Enhanced oil recovery
Rich gas injection