Skip to main content
U.S. Department of Energy
Office of Scientific and Technical Information

Updated sustainability status of cadmium telluride thin‐film photovoltaic systems and projections

Journal Article · · Progress in Photovoltaics
DOI:https://doi.org/10.1002/pip.3837· OSTI ID:2204264

This paper provides a comprehensive assessment of the up-to-date life-cycle sustainability status of cadmium-telluride based photovoltaic (PV) systems. Current production modules (Series 6 and Series 7) are analyzed in terms of their energy performance and environmental footprint and compared with the older series 4 module production and current single-crystalline Silicon (sc-Si) module production. For fixed-tilt systems with Series 6 modules operating under average US irradiation of 1800 kWh/m2/year, the global warming potential (GWP) is reduced from 16 g CO2eq/kWh in Series 4 systems to 10 CO2eq/kWh in Series 6 systems. For operation in US-SW irradiation of 2300 kWh/m2/year, the GWP is reduced from 11 to 8 CO2eq/kWh and for 1-axis tracking systems operating in Phoenix, Arizona, with point-of array irradiation of 3051 kWh/m2/year the GWP is reduced to 6.5 CO2eq/kWh. Similar reductions have happened in all environmental indicators. Energy payback times (EPBT) of currently installed systems range from 0.6 years for fixed–tilt ground–mounted installations at average US irradiation at latitude tilt installations to 0.3 years for one-axis trackers at high US-SW irradiation, considering average fossil-fuel dominated electricity grids with fuel to electricity conversion efficiency of 0.3. The resulting energy return on energy investment (EROI) also depends on the conversion efficiency of the electricity grid and on the operation life expectance. For a 30-year operational life and grid conversion efficiency of 0.3, EROI ranges from 50 (at US average irradiation) to 70 for US-SW irradiation. The EROI declines with increased grid conversion efficiency; for CdTe PV operating in south California with grid conversion efficiency of 49%, the EROI is about 50 and is projected to fall to 30 when the state's 2030 target of 80% renewable energy penetration materializes. Material alternatives that show a potential of further reductions in degradation rates and materials for enhanced encapsulation that would enable longer operation lives have also been investigated. A degradation rate of 0.3%/year, which has been verified by accelerated testing, is assumed in 30-year scenarios; this is projected to be reduced to 0.2%/year in the near-term and potentially to 0.1%/year in the longer term. With such low degradation rates and enhanced edge-sealing, modules can last 40- to 50-years. Consequently, all impact indicators will be proportionally reduced while EROI will increase. This detailed LCA was conducted according to ISO standards and IEA PVPS Task 12 guidelines. Furthermore, the study revealed that the choices of system models, methods and temporal system boundaries can significantly impact the results and points out to the need to include assumptions regarding these choices in the “transparency in reporting” requirements listed in the IEA PVPS Task 12 Guidelines.

Research Organization:
Columbia University, New York, NY (United States)
Sponsoring Organization:
USDOE Office of Energy Efficiency and Renewable Energy (EERE), Renewable Power Office. Solar Energy Technologies Office
Grant/Contract Number:
EE0009830
OSTI ID:
2204264
Alternate ID(s):
OSTI ID: 2426961
Journal Information:
Progress in Photovoltaics, Journal Name: Progress in Photovoltaics Journal Issue: 12 Vol. 32; ISSN 1062-7995
Publisher:
WileyCopyright Statement
Country of Publication:
United States
Language:
English

References (50)

Health, safety and environmental risks from the operation of CdTe and CIS thin-film modules journal March 1998
What Are the Energy and Environmental Impacts of Adding Battery Storage to Photovoltaics? A Generalized Life Cycle Assessment journal January 2020
Fate and transport evaluation of potential leaching risks from cadmium telluride photovoltaics journal May 2012
Update of environmental indicators and energy payback time of CdTe PV systems in Europe journal January 2011
Energy pay‐back time: methodological caveats and future scenarios journal January 2012
Implications for CdTe and CIGS technologies production costs of indium and tellurium scarcity: Effects of indium and tellurium scarcity journal June 2012
Updated sustainability status of crystalline silicon‐based photovoltaic systems: Life‐cycle energy and environmental impact reduction trends journal June 2021
Life cycle energy demand and carbon emissions of scalable single‐junction and tandem perovskite PV journal July 2021
Emissions and encapsulation of cadmium in CdTe PV modules during fires journal January 2005
Extraction and separation of Cd and Te from cadmium telluride photovoltaic manufacturing scrap journal January 2006
Improved estimates for Te and Se availability from Cu anode slimes and recent price trends journal January 2006
Potential Cd emissions from end-of-life CdTe PV journal November 2011
Toxic materials released from photovoltaic modules during fires: Health risks journal June 1990
A Life Cycle Assessment of a recovery process from End-of-Life Photovoltaic Panels journal May 2021
Sustainable urban electricity supply chain – Indicators of material recovery and energy savings from crystalline silicon photovoltaic panels end-of-life journal November 2018
The technical, geographical, and economic feasibility for solar energy to supply the energy needs of the US journal February 2009
Cadmium flows and emissions from CdTe PV: future expectations journal September 2010
Producer responsibility and recycling solar photovoltaic modules journal November 2010
Landfill waste and recycling: Use of a screening-level risk assessment tool for end-of-life cadmium telluride (CdTe) thin-film photovoltaic (PV) panels journal May 2014
Crystalline silicon photovoltaic recycling planning: macro and micro perspectives journal March 2014
Cadmium telluride leaching behavior: Discussion of Zeng et al. (2015) journal November 2015
Kinetics study on separation of cadmium from tellurium in acidic solution media using ion-exchange resins journal October 2005
Potential environmental hazards of photovoltaic panel disposal: Discussion of Tammaro et al. (2015) journal February 2017
Leaching of cadmium and tellurium from cadmium telluride (CdTe) thin-film solar panels under simulated landfill conditions journal August 2017
Dynamic modeling of cadmium substance flow with zinc and steel demand in Japan journal April 2012
Future recycling flows of tellurium from cadmium telluride photovoltaic waste journal December 2012
Substance flow analysis of cadmium in Korea journal February 2013
Life cycle impact analysis of cadmium in CdTe PV production journal August 2004
Life cycle inventory analysis of the production of metals used in photovoltaics journal April 2009
Sustainability of photovoltaics: The case for thin-film solar cells journal December 2009
Review on life cycle assessment of energy payback and greenhouse gas emission of solar photovoltaic systems journal March 2013
Geospatial analysis of the energy yield and environmental footprint of different photovoltaic module technologies journal October 2017
Life cycle materials and water management for CdTe photovoltaics journal December 2013
Energy payback time and carbon footprint of commercial photovoltaic systems journal December 2013
Glass needs for a growing photovoltaics industry journal January 2015
CdTe photovoltaics: Life cycle environmental profile and comparisons journal May 2007
Manufacturing of CdTe thin film photovoltaic modules journal August 2011
Emissions from Photovoltaic Life Cycles journal March 2008
Design and Optimization of Photovoltaics Recycling Infrastructure journal November 2010
Direct Te Mining: Resource Availability and Impact on Cumulative Energy Demand of CdTe PV Life Cycles journal January 2013
Assessment of Leaching Tests for Evaluating Potential Environmental Impacts of PV Module Field Breakage journal November 2015
Considering the Total Cost of Electricity From Sunlight and the Alternatives [Point of View] journal March 2015
Economic Feasibility of Recycling Photovoltaic Modules: Survey and Model journal November 2010
The Impact of Tellurium Supply on Cadmium Telluride Photovoltaics journal May 2010
Glossary of terms used in toxicology, 2nd edition (IUPAC Recommendations 2007) journal January 2007
Cadmium-telluride—Material for thin film solar cells journal October 1998
Sustainability metrics for extending thin-film photovoltaics to terawatt levels journal April 2012
The Energy and Environmental Performance of Ground-Mounted Photovoltaic Systems—A Timely Update journal August 2016
Experimental Studies on the Flammability and Fire Hazards of Photovoltaic Modules journal July 2015
Comment on “Long-term leaching of photovoltaic modules” journal December 2017

Cited By (1)


Similar Records

The Energy and Environmental Performance of Ground-Mounted Photovoltaic Systems—A Timely Update
Journal Article · Mon Aug 08 00:00:00 EDT 2016 · Energies · OSTI ID:1459166

Life-Cycle Analysis of Potentially Longer Life Expectancy CdTe PV Modules
Journal Article · Sun Jun 11 00:00:00 EDT 2023 · Conference Record of the IEEE Photovoltaic Specialists Conference · OSTI ID:2204265