Investigations of ash fouling with cattle wastes as reburn fuel in a small-scale boiler burner under transient conditions
- Texas A&
Fouling behavior under reburn conditions was investigated with cattle wastes (termed as feedlot biomass, FB) and coal as reburn fuels under a transient condition and short-time operation. A small-scale (30 kW or 100,000 Btu/hr) boiler burner research facility was used for the reburn experiments. The fuels considered for these experiments were natural gas (NG) for the ashless case, pure coal, pure FB, and blends of coal and FB. Two parameters that were used to characterize the ash 'fouling' were (1) the overall heat-transfer coefficient (OHTC) when burning NG and solid fuels as reburn fuels, and (2) the combustible loss through ash deposited on the surfaces of heat exchanger tubes and the bottom ash in the ash port. A new methodology is presented for determining ash fouling behavior under transient conditions. Results on the OHTCs for solid reburn fuels are compared with the OHTCs for NG. It was found that the growth of the layer of ash depositions over longer periods typically lowers OHTC, and the increased concentration of ash in gas phase promotes radiation in high-temperature zones during initial periods while decreasing the heat transfer in low-temperature zones. The ash analyses indicated that the bottom ash in the ash port contained a smaller percentage of combustibles with a higher FB percentage in the fuels, indicating better performance compared with coal because small particles in FB burn faster and the FB has higher volatile matter on a dry ash-free basis promoting more burn out. 16 refs., 12 figs., 6 tabs.
- OSTI ID:
- 21049755
- Journal Information:
- Journal of the Air and Waste Management Association, Vol. 58, Issue 4; Other Information: kannamalai@tamu.edu; ISSN 1047-3289
- Country of Publication:
- United States
- Language:
- English
Similar Records
Reburning of Animal Waste Based Biomass with Coal for NOx Reduction, Part I: Feedlot Biomass (FB) and Coal:FB Blends
Waste Coal Fines Reburn for NOx and Mercury Emission Reduction