Catalytic open-circuit passivation by thin metal oxide films of p-Si anodes in aqueous alkaline electrolytes

Fu, Harold J.; Buabthong, Pakpoom; Ifkovits, Zachary Philip; Yu, Weilai; Brunschwig, Bruce S.; Lewis, Nathan S.

doi:10.1039/d1ee03040j

Title: Catalytic open-circuit passivation by thin metal oxide films of p-Si anodes in aqueous alkaline electrolytes

Journal Article · Mon Nov 29 00:00:00 EST 2021 · Energy & Environmental Science

DOI:https://doi.org/10.1039/d1ee03040j· OSTI ID:1978786

^[1];

^[1]

California Institute of Technology (CalTech), Pasadena, CA (United States)

Ni and NiO_x-based protective thin films are shown to catalyze the oxidation of Si in the presence of O₂ in strongly alkaline KOH(aq) even in the absence of illumination. The O₂ in solution drove the open-circuit potential of the electrode to >0.4 V, which is positive of the Si passivation potential. The elevated electrochemical potential of the surface promoted formation of passive oxides on exposed Si regions of Si/Ni electrodes. Catalytic passivation of Si extended the durability of an np⁺-Si(100)/NiO_x photoanode to >400 h while operating under simulated day/night cycles. In contrast, electrodes without a Ni(O_x) layer and/or without O₂ in solution displayed direct etching of the Si and corrosion pitting during non-illuminated, simulated nighttime episodes of day/night cycling. The O₂-derived catalyzed passivation of Si using thin films can be generalized to multiple phases of NiO_x as well as to materials other than Ni. Finally, relative to operation in aqueous alkaline conditions, decreasing the pH of the electrolyte decreased the dissolution rate of the protective oxide layer formed by the catalyzed passivation process, and consequently increased the durability of the photoanode, but yielded lower photoelectrode fill factors for water oxidation due to the relatively large kinetic overpotentials for the electrocatalyzed oxygen-evolution reaction at near-neutral pH.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: California Institute of Technology (CalTech), Pasadena, CA (United States)

Sponsoring Organization:: USDOE Office of Science (SC), Basic Energy Sciences (BES)

Grant/Contract Number:: SC0004993; SC0022087

OSTI ID:: 1978786

Alternate ID(s):: OSTI ID: 1834965

Journal Information:: Energy & Environmental Science, Vol. 15, Issue 1; ISSN 1754-5692

Publisher:: Royal Society of ChemistryCopyright Statement

Country of Publication:: United States

Language:: English

References (40)

Oxidation kinetics of thin and ultrathin cobalt films Smardz, L.; Köbler, U.; Zinn, W. Journal of Applied Physics, Vol. 71, Issue 10 https://doi.org/10.1063/1.351378	journal	May 1992
Structural Evaluation of Silicon Oxide Films Pliskin, W. A.; Lehman, H. S. Journal of The Electrochemical Society, Vol. 112, Issue 10 https://doi.org/10.1149/1.2423333	journal	January 1965
A Stabilized, Intrinsically Safe, 10% Efficient, Solar-Driven Water-Splitting Cell Incorporating Earth-Abundant Electrocatalysts with Steady-State pH Gradients and Product Separation Enabled by a Bipolar Membrane Sun, Ke; Liu, Rui; Chen, Yikai Advanced Energy Materials, Vol. 6, Issue 13 https://doi.org/10.1002/aenm.201600379	journal	April 2016
Strategies for stable water splitting via protected photoelectrodes Bae, Dowon; Seger, Brian; Vesborg, Peter C. K. Chemical Society Reviews, Vol. 46, Issue 7 https://doi.org/10.1039/C6CS00918B	journal	January 2017
Etching of Silicon in NaOH Solutions Allongue, P. Journal of The Electrochemical Society, Vol. 140, Issue 4 https://doi.org/10.1149/1.2056190	journal	January 1993
Enhanced oxygen evolution activity by NiO _x and Ni(OH) ₂ nanoparticles Stern, Lucas-Alexandre; Hu, Xile Faraday Discuss., Vol. 176 https://doi.org/10.1039/C4FD00120F	journal	January 2014
Improved Electrochemical Phase Diagrams from Theory and Experiment: The Ni–Water System and Its Complex Compounds Huang, L. -F.; Hutchison, M. J.; Santucci, R. J. The Journal of Physical Chemistry C, Vol. 121, Issue 18 https://doi.org/10.1021/acs.jpcc.7b02771	journal	May 2017
Characterization of Electronic Transport through Amorphous TiO ₂ Produced by Atomic Layer Deposition Nunez, Paul; Richter, Matthias H.; Piercy, Brandon D. The Journal of Physical Chemistry C, Vol. 123, Issue 33 https://doi.org/10.1021/acs.jpcc.9b04434	journal	June 2019
The influence of oxidizing agents on etching and passivation of silicon in KOH solution Xia, X. H.; Kelly, J. J. Electrochimica Acta, Vol. 45, Issue 28 https://doi.org/10.1016/S0013-4686(00)00616-2	journal	October 2000
Thin-Film Materials for the Protection of Semiconducting Photoelectrodes in Solar-Fuel Generators Hu, Shu; Lewis, Nathan S.; Ager, Joel W. The Journal of Physical Chemistry C, Vol. 119, Issue 43 https://doi.org/10.1021/acs.jpcc.5b05976	journal	October 2015
Enhanced stability of silicon for photoelectrochemical water oxidation through self-healing enabled by an alkaline protective electrolyte Fu, Harold J.; Moreno-Hernandez, Ivan A.; Buabthong, Pakpoom Energy & Environmental Science, Vol. 13, Issue 11 https://doi.org/10.1039/D0EE02250K	journal	January 2020
Study of the Orientation Dependent Etching and Initial Anodization of Si in Aqueous KOH Faust, J. W.; Palik, E. D. Journal of The Electrochemical Society, Vol. 130, Issue 6 https://doi.org/10.1149/1.2119964	journal	June 1983
High-Performance Silicon Photoanodes Passivated with Ultrathin Nickel Films for Water Oxidation Kenney, M. J.; Gong, M.; Li, Y. Science, Vol. 342, Issue 6160 https://doi.org/10.1126/science.1241327	journal	November 2013
Solubility and solubility product of crystalline Ni(OH)2 Mattigod, Shas V.; Rai, Dhanpat; Felmy, Andrew R. Journal of Solution Chemistry, Vol. 26, Issue 4 https://doi.org/10.1007/BF02767678	journal	April 1997
X-ray Photoelectron Spectroscopy and Resonant X-ray Spectroscopy Investigations of Interactions between Thin Metal Catalyst Films and Amorphous Titanium Dioxide Photoelectrode Protection Layers Richter, Matthias H.; Cheng, Wen-Hui; Crumlin, Ethan J. Chemistry of Materials, Vol. 33, Issue 4 https://doi.org/10.1021/acs.chemmater.0c04043	journal	February 2021
Elucidating the performance and unexpected stability of partially coated water-splitting silicon photoanodes Oh, Kiseok; Mériadec, Cristelle; Lassalle-Kaiser, Benedikt Energy & Environmental Science, Vol. 11, Issue 9 https://doi.org/10.1039/C8EE00980E	journal	January 2018
Ferricyanide reduction as a probe for the surface chemistry of silicon in aqueous alkaline solutions Bressers, P. M. M. C.; Pagano, S. A. S. P.; Kelly, J. J. Journal of Electroanalytical Chemistry, Vol. 391, Issue 1-2 https://doi.org/10.1016/0022-0728(95)03908-Y	journal	July 1995
The importance of nickel oxyhydroxide deprotonation on its activity towards electrochemical water oxidation Diaz-Morales, Oscar; Ferrus-Suspedra, David; Koper, Marc T. M. Chemical Science, Vol. 7, Issue 4 https://doi.org/10.1039/C5SC04486C	journal	January 2016
Interface engineering of the photoelectrochemical performance of Ni-oxide-coated n-Si photoanodes by atomic-layer deposition of ultrathin films of cobalt oxide Zhou, Xinghao; Liu, Rui; Sun, Ke Energy & Environmental Science, Vol. 8, Issue 9 https://doi.org/10.1039/C5EE01687H	journal	January 2015
Failure modes of protection layers produced by atomic layer deposition of amorphous TiO ₂ on GaAs anodes Buabthong, Pakpoom; Ifkovits, Zachary P.; Kempler, Paul A. Energy & Environmental Science, Vol. 13, Issue 11 https://doi.org/10.1039/D0EE02032J	journal	January 2020
Surface Morphology of p-Type (100) Silicon Etched in Aqueous Alkaline Solution Bressers, P. M. M. C. Journal of The Electrochemical Society, Vol. 143, Issue 5 https://doi.org/10.1149/1.1836710	journal	January 1996
A comprehensive review of Pt electrocatalysts for the oxygen reduction reaction: Nanostructure, activity, mechanism and carbon support in PEM fuel cells Sui, Sheng; Wang, Xiaoying; Zhou, Xintong Journal of Materials Chemistry A, Vol. 5, Issue 5 https://doi.org/10.1039/C6TA08580F	journal	January 2017
X-ray photoelectron spectroscopic chemical state quantification of mixed nickel metal, oxide and hydroxide systems Biesinger, Mark C.; Payne, Brad P.; Lau, Leo W. M. Surface and Interface Analysis, Vol. 41, Issue 4 https://doi.org/10.1002/sia.3026	journal	April 2009
Amorphous TiO2 coatings stabilize Si, GaAs, and GaP photoanodes for efficient water oxidation Hu, S.; Shaner, M. R.; Beardslee, J. A. Science, Vol. 344, Issue 6187 https://doi.org/10.1126/science.1251428	journal	May 2014
An electrochemical engineering assessment of the operational conditions and constraints for solar-driven water-splitting systems at near-neutral pH Singh, Meenesh R.; Papadantonakis, Kimberly; Xiang, Chengxiang Energy & Environmental Science, Vol. 8, Issue 9 https://doi.org/10.1039/C5EE01721A	journal	January 2015
Stabilization of Si microwire arrays for solar-driven H ₂ O oxidation to O ₂ (g) in 1.0 M KOH(aq) using conformal coatings of amorphous TiO ₂ Shaner, Matthew R.; Hu, Shu; Sun, Ke Energy & Environmental Science, Vol. 8, Issue 1 https://doi.org/10.1039/C4EE03012E	journal	January 2015
Protection of Si photocathode using TiO2 deposited by high power impulse magnetron sputtering for H2 evolution in alkaline media Bae, Dowon; Shayestehaminzadeh, Seyedmohammad; Thorsteinsson, Einar B. Solar Energy Materials and Solar Cells, Vol. 144 https://doi.org/10.1016/j.solmat.2015.10.020	journal	January 2016
Nickel–Iron Oxyhydroxide Oxygen-Evolution Electrocatalysts: The Role of Intentional and Incidental Iron Incorporation Trotochaud, Lena; Young, Samantha L.; Ranney, James K. Journal of the American Chemical Society, Vol. 136, Issue 18 https://doi.org/10.1021/ja502379c	journal	April 2014
Ultrathin Cobalt Oxide Overlayer Promotes Catalytic Activity of Cobalt Nitride for the Oxygen Reduction Reaction Abroshan, Hadi; Bothra, Pallavi; Back, Seoin The Journal of Physical Chemistry C, Vol. 122, Issue 9 https://doi.org/10.1021/acs.jpcc.7b12643	journal	January 2018
Improved Stability of Atomic Layer Deposited Amorphous TiO ₂ Photoelectrode Coatings by Thermally Induced Oxygen Defects Hannula, Markku; Ali-Löytty, Harri; Lahtonen, Kimmo Chemistry of Materials, Vol. 30, Issue 4 https://doi.org/10.1021/acs.chemmater.7b02938	journal	February 2018
Anisotropy in the Anodic Oxidation of Silicon in KOH Solution Philipsen, Harold G. G.; Kelly, John J. The Journal of Physical Chemistry B, Vol. 109, Issue 36 https://doi.org/10.1021/jp052595w	journal	September 2005
Stable solar-driven oxidation of water by semiconducting photoanodes protected by transparent catalytic nickel oxide films Sun, Ke; Saadi, Fadl H.; Lichterman, Michael F. Proceedings of the National Academy of Sciences, Vol. 112, Issue 12, p. 3612-3617 https://doi.org/10.1073/pnas.1423034112	journal	March 2015
Silicon (100)/SiO2 by XPS Jensen, David S.; Kanyal, Supriya S.; Madaan, Nitesh Surface Science Spectra, Vol. 20, Issue 1 https://doi.org/10.1116/11.20121101	journal	September 2013
Bias-Dependent Etching of Silicon in Aqueous KOH Glembocki, Orest J. Journal of The Electrochemical Society, Vol. 132, Issue 1 https://doi.org/10.1149/1.2113750	journal	January 1985
Single Cobalt Atoms with Precise N-Coordination as Superior Oxygen Reduction Reaction Catalysts Yin, Peiqun; Yao, Tao; Wu, Yuen Angewandte Chemie International Edition, Vol. 55, Issue 36 https://doi.org/10.1002/anie.201604802	journal	August 2016
New interpretations of XPS spectra of nickel metal and oxides Grosvenor, Andrew P.; Biesinger, Mark C.; Smart, Roger St. C. Surface Science, Vol. 600, Issue 9 https://doi.org/10.1016/j.susc.2006.01.041	journal	May 2006
Performance and failure modes of Si anodes patterned with thin-film Ni catalyst islands for water oxidation Sun, Ke; Ritzert, Nicole L.; John, Jimmy Sustainable Energy & Fuels, Vol. 2, Issue 5 https://doi.org/10.1039/C7SE00583K	journal	January 2018
Stable Solar-Driven Water Oxidation to O ₂ (g) by Ni-Oxide-Coated Silicon Photoanodes Sun, Ke; McDowell, Matthew T.; Nielander, Adam C. The Journal of Physical Chemistry Letters, Vol. 6, Issue 4 https://doi.org/10.1021/jz5026195	journal	January 2015
Resolving surface chemical states in XPS analysis of first row transition metals, oxides and hydroxides: Cr, Mn, Fe, Co and Ni Biesinger, Mark C.; Payne, Brad P.; Grosvenor, Andrew P. Applied Surface Science, Vol. 257, Issue 7, p. 2717-2730 https://doi.org/10.1016/j.apsusc.2010.10.051	journal	January 2011
570 mV photovoltage, stabilized n-Si/CoO _x heterojunction photoanodes fabricated using atomic layer deposition Zhou, Xinghao; Liu, Rui; Sun, Ke Energy & Environmental Science, Vol. 9, Issue 3 https://doi.org/10.1039/C5EE03655K	journal	January 2016

Similar Records

Enhanced stability of silicon for photoelectrochemical water oxidation through self-healing enabled by an alkaline protective electrolyte

Journal Article · Tue Oct 06 00:00:00 EDT 2020 · Energy & Environmental Science · OSTI ID:1978786

Fu, Harold J.; Moreno-Hernandez, Ivan A.; Buabthong, Pakpoom; +3 more

570 mV photovoltage, stabilized n-Si/CoO_x heterojunction photoanodes fabricated using atomic layer deposition

Journal Article · Fri Jan 08 00:00:00 EST 2016 · Energy & Environmental Science · OSTI ID:1978786

Zhou, Xinghao; Liu, Rui; Sun, Ke; +3 more

The Influence of Structure and Processing on the Behavior of TiO₂ Protective Layers for Stabilization of n-Si/TiO₂/Ni Photoanodes for Water Oxidation

Journal Article · Wed Jun 17 00:00:00 EDT 2015 · ACS Applied Materials and Interfaces · OSTI ID:1978786

McDowell, Matthew T.; Lichterman, Michael F.; Carim, Azhar I.; +4 more

Related Subjects

37 INORGANIC, ORGANIC, PHYSICAL, AND ANALYTICAL CHEMISTRY
Chemistry
Energy & Fuels
Engineering
Environmental Sciences & Ecology

Title: Catalytic open-circuit passivation by thin metal oxide films of p-Si anodes in aqueous alkaline electrolytes

Citation Formats

References (40)

Similar Records

Related Subjects