Calibration of an explosives vapor generator based on vapor diffusion from a condensed phase
- Sandia National Labs., Albuquerque, NM (United States)
- New Mexico State Univ., Las Cruces, NM (United States). Dept. of Chemistry and Biochemistry
- Varian Associates, Palo Alto, CA (United States). Ginzton Research Laboratory
Development of a vapor generator for consistently producing accurate amounts of vapor from low vapor pressure explosive materials is a pressing need within the explosives detection community. Of particular importance for reproducibility and widespread acceptance of results is the correlation of such a vapor generator to a National Institute of Standards and Technology (NIST) mass standard. This paper describes an explosives vapor generator recently developed at Varian in which a solid explosive sample in a precision bore glass tube is put in an oven at constant temperature, and vapor diff-using from the top of the tube is entrained in a carrier gas flow. The rate of vapor output is thus dependent on both the equilibrium vapor pressure of the solid at oven temperature and the rate of diffusion up the length of the tube. Correlation to a NIST mass standard is achieved by periodic weighing of the sample tube on a microbalance. We report results obtained with the explosives TNT and RDX. Results for TNT show that the mass output rate is constant over hundreds of hours of continuous use, with outputs of {approximately} 10--2000 pg/sec for oven temperatures in the range of 60--120{degrees}C. Both the mass loss experiments and calibration with an ion mobility spectrometer (IMS) give a TNT mass output value of 85 pg/sec at 79{degrees}C, and this result is supported by transport theory calculations. Mass loss curves for RDX are also linear with time, and show the expected exponential increase of mass output with oven temperature.
- Research Organization:
- Sandia National Lab. (SNL-NM), Albuquerque, NM (United States)
- Sponsoring Organization:
- USDOE, Washington, DC (United States); Federal Aviation Administration, Washington, DC (United States)
- DOE Contract Number:
- AC04-94AL85000
- OSTI ID:
- 195758
- Report Number(s):
- SAND-95-2724C; CONF-951263-1; ON: DE96004307
- Resource Relation:
- Conference: 5. international symposium on analysis and detection of explosives, Chantilly, VA (United States), 4-8 Dec 1995; Other Information: PBD: [1995]
- Country of Publication:
- United States
- Language:
- English
Similar Records
Design and calibration of pulsed vapor generators for 2,4,6-trinitrotoluene, cyclo-1,3,5-trimethylene-2,4,6-trinitramine, and pentaerythritol tetranitrate
Design and calibration of pulsed vapor generators for TNT, RDX and PETN