Quantifying Dynamic On-State Resistance of GaN HEMTs for Power Converter Design via a Survey of Low and High Voltage Devices

Foulkes, Thomas; Modeer, Tomas; Pilawa-Podgurski, Robert N.

doi:10.1109/jestpe.2020.3024930

Title: Quantifying Dynamic On-State Resistance of GaN HEMTs for Power Converter Design via a Survey of Low and High Voltage Devices

Journal Article · Mon Sep 21 00:00:00 EDT 2020 · IEEE Journal of Emerging and Selected Topics in Power Electronics

DOI:https://doi.org/10.1109/jestpe.2020.3024930· OSTI ID:1870981

^[1]; Modeer, Tomas ^[2];

^[3]

Univ. of Illinois at Urbana-Champaign, IL (United States)
Univ. of Illinois at Urbana-Champaign, IL (United States); SCiBreak AB, Jarfalla (Sweden)
Univ. of Illinois at Urbana-Champaign, IL (United States); Univ. of California, Berkeley, CA (United States)

Designing and optimizing high switching frequency, ultra-efficient converters requires detailed knowledge of the behavior and parasitic parameters for both active and passive components. Recently, wide bandgap transistors have enabled simultaneous increases in both switching frequency and efficiency due to higher maximum operating junction temperature limits, lower dc on-state resistances, and reduced parasitic inductances and capacitances. Yet, the early acceptance of gallium-nitride (GaN) switches was plagued by detrimental dynamic on-state resistance effects. This complex phenomenon for GaN devices is characterized by deviations in on-state resistance from dc operating characteristics based on design choices such as the magnitude and duration of both voltage and current stress, switching mode, and junction temperature. While device manufacturers have made improvements compared to early generation devices, experimental evidence from a survey of commercial GaN transistors highlight measurable change in on-state resistance still exists due to variations in voltage stress during hard-switching operation. After sharing insights for obtaining low noise measurements, an analysis method along with two metrics are proposed to characterize dynamic on-state resistance measurements for power electronics designers. Furthermore, quantifying the performance of GaN devices with standardized metrics facilitates a fair comparison between different GaN device technologies during converter development, enables manufacturing qualification for GaN switches, and provides a benchmark to catalyze improvement for the next generation of GaN device development.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Power Integration Technology, LLC, Alameda, CA (United States)

Sponsoring Organization:: USDOE Office of Energy Efficiency and Renewable Energy (EERE), Renewable Power Office. Solar Energy Technologies Office; National Science Foundation (NSF); National Aeronautics and Space Administration (NASA)

Grant/Contract Number:: EE0008138; DGE-1144245; EEC-1449548; NASA-NNX14AL79A

OSTI ID:: 1870981

Journal Information:: IEEE Journal of Emerging and Selected Topics in Power Electronics, Vol. 9, Issue 4; ISSN 2168-6777

Publisher:: IEEECopyright Statement

Country of Publication:: United States

Language:: English

References (45)

Trapping effects in GaN and SiC microwave FETs Binari, S. C.; Klein, P. B.; Kazior, T. E. Proceedings of the IEEE, Vol. 90, Issue 6 https://doi.org/10.1109/JPROC.2002.1021569	journal	June 2002
Low‐frequency noise in AlGaN/GaN HEMT structures with AlN thin film layer Vitusevich, S. A.; Antoniuk, O. A.; Petrychuk, M. V. physica status solidi c, Vol. 3, Issue 6 https://doi.org/10.1002/pssc.200565138	journal	June 2006
On-State Voltage Measurement of Fast Switching Power Semiconductors Guacci, Mattia; Bortis, Dominik; Kolar, Johann W. CPSS Transactions on Power Electronics and Applications, Vol. 3, Issue 2 https://doi.org/10.24295/CPSSTPEA.2018.00016	journal	June 2018
Suppression of Dynamic On-Resistance Increase and Gate Charge Measurements in High-Voltage GaN-HEMTs With Optimized Field-Plate Structure Saito, W.; Nitta, T.; Kakiuchi, Y. IEEE Transactions on Electron Devices, Vol. 54, Issue 8 https://doi.org/10.1109/TED.2007.901150	journal	August 2007
Current-collapse-free operations up to 850 V by GaN-GIT utilizing hole injection from drain Kaneko, Saichiro; Kuroda, Masayuki; Yanagihara, Manabu 2015 IEEE 27th International Symposium on Power Semiconductor Devices & IC's (ISPSD) https://doi.org/10.1109/ISPSD.2015.7123384	conference	May 2015
Describing the uncertainties in experimental results Moffat, Robert J. Experimental Thermal and Fluid Science, Vol. 1, Issue 1 https://doi.org/10.1016/0894-1777(88)90043-X	journal	January 1988
1200-V Normally Off GaN-on-Si Field-Effect Transistors With Low Dynamic on -Resistance IEEE Electron Device Letters, Vol. 32, Issue 5 https://doi.org/10.1109/LED.2011.2118190	journal	May 2011
Developing a standardized method for measuring and quantifying dynamic on-state resistance via a survey of low voltage GaN HEMTs Foulkes, Thomas; Modeer, Tomas; Pilawa-Podgurski, Robert C. N. 2018 IEEE Applied Power Electronics Conference and Exposition (APEC) https://doi.org/10.1109/APEC.2018.8341401	conference	March 2018
Dynamic on-State Resistance Test and Evaluation of GaN Power Devices Under Hard- and Soft-Switching Conditions by Double and Multiple Pulses Li, Rui; Wu, Xinke; Yang, Shu IEEE Transactions on Power Electronics, Vol. 34, Issue 2 https://doi.org/10.1109/TPEL.2018.2844302	journal	February 2019
Product-level reliability of GaN devices Bahl, Sandeep R.; Ruiz, Daniel; Lee, Dong Seup 2016 IEEE International Reliability Physics Symposium (IRPS) https://doi.org/10.1109/IRPS.2016.7574528	conference	April 2016
Extraction of Dynamic On-Resistance in GaN Transistors: Under Soft- and Hard-Switching Conditions Lu, Bin; Palacios, Tomas; Risbud, Dilip 2011 IEEE Compound Semiconductor Integrated Circuit Symposium (CSICS) https://doi.org/10.1109/CSICS.2011.6062461	conference	October 2011
Trapping induced parasitic effects in GaN-HEMT for power switching applications Meneghesso, Gaudenzio; Meneghini, Matteo; Zanoni, Enrico 2015 International Conference on IC Design & Technology (ICICDT) https://doi.org/10.1109/ICICDT.2015.7165899	conference	June 2015
Design and control of a GaN-based, 13-level, flying capacitor multilevel inverter Barth, Christopher B.; Foulkes, Thomas; Chung, Won Ho 2016 IEEE 17th Workshop on Control and Modeling for Power Electronics (COMPEL) https://doi.org/10.1109/COMPEL.2016.7556770	conference	June 2016
Investigation of the Dynamic On-State Resistance of 600 V Normally-Off and Normally-On GaN HEMTs Badawi, Nasser; Hilt, Oliver; Bahat-Treidel, Eldad IEEE Transactions on Industry Applications, Vol. 52, Issue 6 https://doi.org/10.1109/TIA.2016.2585564	journal	November 2016
Through recessed and regrowth gate technology for realizing process stability of GaN-GITs Okita, Hideyuki; Hikita, Masahiro; Nishio, Akihiko 2016 28th International Symposium on Power Semiconductor Devices and ICs (ISPSD) https://doi.org/10.1109/ISPSD.2016.7520768	conference	June 2016
The ideal switch is not enough Kolar, J. W.; Bortis, D.; Neumayr, D. 2016 28th International Symposium on Power Semiconductor Devices and ICs (ISPSD) https://doi.org/10.1109/ISPSD.2016.7520767	conference	June 2016
GaN HEMT modeling for power and RF applications using ASM-HEMT Ghosh, Sudip; Ahsan, Sheikh Aamir; Dasgupta, Avirup 2016 3rd International Conference on Emerging Electronics (ICEE) https://doi.org/10.1109/ICEmElec.2016.8074569	conference	December 2016
Buffer Design to Minimize Current Collapse in GaN/AlGaN HFETs Uren, Michael J.; Moreke, Janina; Kuball, Martin IEEE Transactions on Electron Devices, Vol. 59, Issue 12 https://doi.org/10.1109/TED.2012.2216535	journal	December 2012
Total suppression of dynamic-ron in AlGaN/GaN-HEMTs through proton irradiation Meneghini, M.; Tajalli, A.; Moens, P. 2017 IEEE International Electron Devices Meeting (IEDM) https://doi.org/10.1109/IEDM.2017.8268492	conference	December 2017
Very High Frequency PWM Buck Converters Using Monolithic GaN Half-Bridge Power Stages With Integrated Gate Drivers Zhang, Yuanzhe; Rodriguez, Miguel; Maksimovic, Dragan IEEE Transactions on Power Electronics, Vol. 31, Issue 11 https://doi.org/10.1109/TPEL.2015.2513058	journal	November 2016
Characterisation and Modeling of Gallium Nitride Power Semiconductor Devices Dynamic On-State Resistance Li, Ke; Evans, Paul Leonard; Johnson, Christopher Mark IEEE Transactions on Power Electronics, Vol. 33, Issue 6 https://doi.org/10.1109/TPEL.2017.2730260	journal	June 2018
Measuring Dynamic On Resistance in GaN Transistors at MHz Frequencies Galapon, Bryson J.; Hanson, Alex J.; Perreault, David J. 2018 IEEE 19th Workshop on Control and Modeling for Power Electronics (COMPEL) https://doi.org/10.1109/COMPEL.2018.8460051	conference	June 2018
ZVS of Power MOSFETs Revisited Kasper, Matthias; Burkat, Ralph; Deboy, Ferald IEEE Transactions on Power Electronics https://doi.org/10.1109/TPEL.2016.2574998	journal	January 2016
(Invited) Driving eGaN FETs in High Performance Power Conversion Systems Lidow, Alexander; Strydom, Johan; De Rooij, Michael ECS Transactions, Vol. 41, Issue 8 https://doi.org/10.1149/1.3631490	journal	October 2011
Design of a GaN-based, 9-level flying capacitor multilevel inverter with low inductance layout Modeer, Tomas; Barth, Christopher B.; Pallo, Nathan 2017 IEEE Applied Power Electronics Conference and Exposition (APEC) https://doi.org/10.1109/APEC.2017.7931062	conference	March 2017
C _OSS Losses in 600 V GaN Power Semiconductors in Soft-Switched, High- and Very-High-Frequency Power Converters Zulauf, Grayson; Park, Sanghyeon; Liang, Wei IEEE Transactions on Power Electronics, Vol. 33, Issue 12 https://doi.org/10.1109/TPEL.2018.2800533	journal	December 2018
Modeling of source/drain access resistances and their temperature dependence in GaN HEMTs Ghosh, Sudip; Ahsan, Sheikh Aamir; Chauhan, Yogesh Singh 2016 IEEE International Conference on Electron Devices and Solid-State Circuits (EDSSC) https://doi.org/10.1109/EDSSC.2016.7785254	conference	August 2016
Design, Operation, and Loss Characterization of a 1-kW GaN-Based Three-Level Converter at Cryogenic Temperatures Barth, Christopher B.; Foulkes, Thomas; Azofeifa, Oscar IEEE Transactions on Power Electronics, Vol. 35, Issue 11 https://doi.org/10.1109/TPEL.2020.2989310	journal	November 2020
The impact of surface states on the DC and RF characteristics of AlGaN/GaN HFETs Vetury, R.; Zhang, N. Q.; Keller, S. IEEE Transactions on Electron Devices, Vol. 48, Issue 3 https://doi.org/10.1109/16.906451	journal	March 2001
Techniques towards GaN power transistors with improved high voltage dynamic switching properties Wurfl, J.; Hilt, O.; Bahat-Treidel, E. 2013 IEEE International Electron Devices Meeting (IEDM) https://doi.org/10.1109/IEDM.2013.6724571	conference	December 2013
High-Frequency PWM Buck Converters Using GaN-on-SiC HEMTs Rodriguez, Miguel; Zhang, Yuanzhe; Maksimovic, Dragan IEEE Transactions on Power Electronics, Vol. 29, Issue 5 https://doi.org/10.1109/TPEL.2013.2279212	journal	May 2014
Power-dense multilevel inverter module using interleaved GaN-based phases for electric aircraft propulsion Pallo, Nathan; Foulkes, Thomas; Modeer, Tomas 2018 IEEE Applied Power Electronics Conference and Exposition (APEC) https://doi.org/10.1109/APEC.2018.8341239	conference	March 2018
A 2-kW Single-Phase Seven-Level Flying Capacitor Multilevel Inverter With an Active Energy Buffer Lei, Yutian; Barth, Christopher; Qin, Shibin IEEE Transactions on Power Electronics, Vol. 32, Issue 11 https://doi.org/10.1109/TPEL.2017.2650140	journal	November 2017
Online Vce measurement method for wear-out monitoring of high power IGBT modules Beczkowski, Szymon; Ghimre, Pramod; de Vega, Angel Ruiz 2013 15th European Conference on Power Electronics and Applications (EPE) https://doi.org/10.1109/EPE.2013.6634390	conference	September 2013
Over 10 a operation with switching characteristics of 1.2 kV-class vertical GaN trench MOSFETs on a bulk GaN substrate Oka, Tohru; Ina, Tsutomu; Ueno, Yukihisa 2016 28th International Symposium on Power Semiconductor Devices and ICs (ISPSD) https://doi.org/10.1109/ISPSD.2016.7520877	conference	June 2016
Vertical power diodes in bulk GaN Disney, Don; Nie, Hui; Edwards, Andrew 2014 IEEE 26th International Symposium on Power Semiconductor Devices & IC's (ISPSD) https://doi.org/10.1109/ISPSD.2014.6855957	conference	June 2014
GaN-HEMT dynamic ON-state resistance characterisation and modelling Li, Ke; Evans, Paul; Johnson, Mark 2016 IEEE 17th Workshop on Control and Modeling for Power Electronics (COMPEL) https://doi.org/10.1109/COMPEL.2016.7556732	conference	June 2016
“Leaky Dielectric” Model for the Suppression of Dynamic $R_{\mathrm{ON}}$ in Carbon-Doped AlGaN/GaN HEMTs Uren, Michael J.; Karboyan, Serge; Chatterjee, Indranil IEEE Transactions on Electron Devices, Vol. 64, Issue 7 https://doi.org/10.1109/TED.2017.2706090	journal	July 2017
Methodology for the Study of Dynamic ON-Resistance in High-Voltage GaN Field-Effect Transistors Jin, Donghyun; del Alamo, Jesus A. IEEE Transactions on Electron Devices, Vol. 60, Issue 10 https://doi.org/10.1109/TED.2013.2274477	journal	October 2013
Design of a GaN-Based Interleaved Nine-Level Flying Capacitor Multilevel Inverter for Electric Aircraft Applications Modeer, Tomas; Pallo, Nathan; Foulkes, Thomas IEEE Transactions on Power Electronics, Vol. 35, Issue 11 https://doi.org/10.1109/TPEL.2020.2989329	journal	November 2020
Evidence for temperature-dependent buffer-induced trapping in GaN-on-silicon power transistors Meneghini, M.; Silvestri, R.; Dalcanale, S. 2015 IEEE International Reliability Physics Symposium (IRPS) https://doi.org/10.1109/IRPS.2015.7112687	conference	April 2015
A Fast Voltage Clamp Circuit for the Accurate Measurement of the Dynamic ON-Resistance of Power Transistors Gelagaev, Ratmir; Jacqmaer, Pieter; Driesen, Johan IEEE Transactions on Industrial Electronics, Vol. 62, Issue 2 https://doi.org/10.1109/TIE.2014.2349876	journal	February 2015
A Current-Transient Methodology for Trap Analysis for GaN High Electron Mobility Transistors Joh, Jungwoo; del Alamo, Jesús A. IEEE Transactions on Electron Devices, Vol. 58, Issue 1 https://doi.org/10.1109/TED.2010.2087339	journal	January 2011
Trapping in GaN-based metal-insulator-semiconductor transistors: Role of high drain bias and hot electrons Meneghini, M.; Bisi, D.; Marcon, D. Applied Physics Letters, Vol. 104, Issue 14 https://doi.org/10.1063/1.4869680	journal	April 2014
Bias error reduction using ratios to baseline experiments - Heat transfer case study Chakroun, Walid; Taylor, Robert P.; Steele, W. G. Journal of Thermophysics and Heat Transfer, Vol. 7, Issue 4 https://doi.org/10.2514/3.495	journal	October 1993

Similar Records

Wide-Bandgap Semiconductors

Technical Report · Tue Nov 22 00:00:00 EST 2005 · OSTI ID:1870981

Chinthavali, M S

Characterization and Failure Analysis of 650-V Enhancement-Mode GaN HEMT for Cryogenically Cooled Power Electronics

Journal Article · Mon Oct 28 00:00:00 EDT 2019 · IEEE Journal of Emerging and Selected Topics in Power Electronics · OSTI ID:1870981

Ren, Ren; Gui, Handong; Zhang, Zheyu; +7 more

Design of Low-Inductance Switching Power Cell for GaN HEMT Based Inverter

Journal Article · Thu Mar 01 00:00:00 EST 2018 · IEEE Transactions on Industry Applications · OSTI ID:1870981

Gurpinar, Emre; Iannuzzo, Francesco; Yang, Yongheng; +2 more

Related Subjects

24 POWER TRANSMISSION AND DISTRIBUTION
42 ENGINEERING
14 SOLAR ENERGY
Dynamic on-state resistance
gallium-nitride (GaN)
power transistors
wide bandgap semiconductors

Title: Quantifying Dynamic On-State Resistance of GaN HEMTs for Power Converter Design via a Survey of Low and High Voltage Devices

Citation Formats

References (45)

Similar Records

Related Subjects