Skip to main content
U.S. Department of Energy
Office of Scientific and Technical Information

Experimental investigation of cross flow mixing in a randomly packed bed and streamwise vortex characteristics using particle image velocimetry and proper orthogonal decomposition analysis

Journal Article · · Physics of Fluids
DOI:https://doi.org/10.1063/1.5079303· OSTI ID:1570692
 [1];  [2];  [3];  [2]
  1. Texas A & M Univ., College Station, TX (United States). Dept. of Nuclear Engineering; Texas A&M University
  2. Texas A & M Univ., College Station, TX (United States). Dept. of Mechanical Engineering
  3. Texas A & M Univ., College Station, TX (United States). Dept. of Nuclear Engineering and Dept. of Mechanical Engineering
The study of flow and heat transfer through porous media or randomly packed beds is important as these configurations are widely used in many engineering applications, for example, heat energy storage, chemical catalytic reactors, and nuclear reactors. The flow mixing characteristics in a cross-flow plane of a facility with randomly packed spheres at an aspect ratio of 6.3 were experimentally investigated. The velocity fields at several regions of the cross-flow plane located in the vicinity of the wall and in the pores between spheres were obtained by applying the matched-index-of-refraction and time-resolved particle image velocimetry (TR-PIV) techniques for Reynolds numbers ranging from 700 to 1700. The TR-PIV results revealed various flow patterns in the transverse plane of the packed spheres, including swirling flow structures aligned with the axial flow direction, a strong bypass flow near the enclosure wall, and a circulation region created when the bypass flow ejected into a large spatial gap. When the Reynolds number was increased, the peaks of root-mean-square fluctuating velocities, $$u'_{rms}$$ and $$v'_{rms}$$, were found to increase approximately at the same ratio as the increase in Reynolds number, and the magnitude of the Reynolds stress increased considerably. In addition, the characteristics of flow mixing in different flow regions were investigated via the two-point cross-correlation of fluctuating velocities. Using Taylor’s hypothesis, the vorticity iso-surfaces were constructed. Thus, constructed iso-surfaces showed that shear layers generated from the bypass flow gaps were stretched, broken into smaller flow structures, and then evolved as vortex pairs when entering the neighboring gaps. The results obtained by applying proper orthogonal decomposition (POD) analysis to the velocity fields showed that the statistically dominant flow structures had approximately the same size and shape as those depicted by Taylor’s hypothesis. Vortex characteristics, such as populations, spatial distributions, and strengths, for various spatial regions and Reynolds numbers were obtained by a combination of POD analysis and vortex identification.
Research Organization:
Texas A&M Univ., College Station, TX (United States)
Sponsoring Organization:
USDOE Office of Nuclear Energy (NE)
Grant/Contract Number:
NE0008550
OSTI ID:
1570692
Journal Information:
Physics of Fluids, Journal Name: Physics of Fluids Journal Issue: 2 Vol. 31; ISSN 1070-6631
Publisher:
American Institute of Physics (AIP)Copyright Statement
Country of Publication:
United States
Language:
English

References (87)

Flow and Transport in Porous Media and Fractured Rock: From Classical Methods to Modern Approaches book December 2010
Effective heat transfer parameters for transient packed-bed models journal May 1986
Measurement of two-dimensional velocity fields in porous media by particle image displacement velocimetry journal January 1992
Analysis of two-point velocity measurements in near-wall flows journal December 1995
Experimental studies of model porous media fluid dynamics journal October 1989
Efficient detection of spurious vectors in particle image velocimetry data journal February 1994
Measurement of laminar, transitional and turbulent pipe flow using Stereoscopic-PIV journal December 2006
Optical measurements of pore geometry and fluid velocity in a bed of irregularly packed spheres journal March 2008
Phase correlation processing for DPIV measurements journal March 2008
Evaluation of the performance of high-speed PIV compared to standard PIV in a turbulent jet journal May 2009
Measurement and analysis of the turbulent length scales in jet flows journal September 2010
A fast all-in-one method for automated post-processing of PIV data journal October 2010
A method for automatic estimation of instantaneous local uncertainty in particle image velocimetry measurements journal July 2012
Optical measurement uncertainties due to refractive index mismatch for flow in porous media journal September 2012
An investigation of matched index of refraction technique and its application in optical measurements of fluid flow journal November 2012
Flow characterization using PIV measurements in a low aspect ratio randomly packed porous bed journal March 2013
Refractive index and solubility control of para-cymene solutions for index-matched fluid–structure interaction studies journal November 2015
Time-resolved PIV measurements in a low-aspect ratio facility of randomly packed spheres and flow analysis using modal decomposition journal July 2018
Analysis and interpretation of instantaneous turbulent velocity fields journal September 2000
Measurements of Transitional and Turbulent Flow in a Randomly Packed Bed of Spheres with Particle Image Velocimetry journal November 2016
Transitional and Turbulent Flow in a Bed of Spheres as Measured with Stereoscopic Particle Image Velocimetry journal January 2017
Optical measurements of porosity and fluid motion in packed beds journal January 1986
Axial and radial dispersion in fixed beds journal January 1987
Direct measurement of interstitial velocity field variations in a porous medium using fluorescent-particle image velocimetry journal January 1993
Measurement of porous medium velocity fields and their volumetric averaging characteristics using particle tracking velocimetry journal July 1995
Turbulence model for flow through porous media journal September 1996
Radial porosity distribution in cylindrical beds packed with spheres journal May 1983
A comparison of measured and modeled velocity fields for a laminar flow in a porous medium journal November 2015
Computational fluid dynamic analysis of core bypass flow phenomena in a prismatic VHTR journal September 2010
Robust smoothing of gridded data in one and higher dimensions with missing values journal April 2010
Stereoscopic PIV measurements of near-wall flow in a tightly packed rod bundle with wire spacers journal April 2018
Vortex identification: New requirements and limitations journal August 2007
A method for characterizing cross-sections of vortices in turbulent flows journal October 2012
PIV measurements of turbulent flows in a 61-pin wire-wrapped hexagonal fuel bundle journal June 2017
Stereoscopic particle image velocimetry measurements of flow in a rod bundle with a spacer grid and mixing vanes at a low Reynolds number journal October 2017
Reaction chain modeling of denitrification reactions during a push–pull test journal May 2013
Large eddy simulation in pebble bed gas cooled core reactors journal March 2008
Flow visualization in a pebble bed reactor experiment using PIV and refractive index matching techniques journal November 2008
Bypass flow computations using a one-twelfth symmetric sector for normal operation in a 350MWth prismatic VHTR journal October 2012
Quasi-direct numerical simulation of a pebble bed configuration. Part I: Flow (velocity) field analysis journal October 2013
Quasi-direct numerical simulation of a pebble bed configuration, Part-II: Temperature field analysis journal October 2013
The role of porous media in modeling flow and heat transfer in biological tissues journal December 2003
A general two-equation macroscopic turbulence model for incompressible flow in porous media journal September 1997
A modified form of the κ–ε model for turbulent flows of an incompressible fluid in porous media journal August 2000
Laser Doppler anemometry measurements in an index of refraction matched column in the presence of dispersed beads journal September 2000
Experimental study of eddy structures in a turbulent boundary layer using particle image velocimetry journal July 2005
Investigation of three-dimensional structure of fine scales in a turbulent jet by using cinematographic stereoscopic particle image velocimetry journal February 2008
On the identification of a vortex journal February 1995
Mechanisms for generating coherent packets of hairpin vortices in channel flow journal May 1999
Fundamental Models for Fuel Cell Engineering journal October 2004
Mixing and Reaction Kinetics in Porous Media: An Experimental Pore Scale Quantification journal December 2013
Transverse mixing of conservative and reactive tracers in porous media: Quantification through the concepts of flux-related and critical dilution indices: FLUX-RELATED AND CRITICAL DILUTION INDICES journal February 2011
Intermittent vortex structures in homogeneous isotropic turbulence journal March 1990
Statistical mechanics with three-dimensional particle tracking velocimetry experiments in the study of anomalous dispersion. II. Experiments journal January 2001
On the vortical structure in a round jet journal February 2005
Turbulent flow characteristics in a randomly packed porous bed based on particle image velocimetry measurements journal April 2013
Comparison of vortex identification criteria for planar velocity fields in wall turbulence journal August 2015
Axisymmetric wall jet development in confined jet impingement journal February 2017
Flow organization and heat transfer in two-dimensional tilted convection with aspect ratio 0.5 journal February 2019
Mechanisms of canonical Kelvin-Helmholtz instability suppression in magnetohydrodynamic flows journal February 2019
A general classification of three‐dimensional flow fields journal May 1990
Measurement of fluid velocity inside porous media with a laser anemometer journal January 1975
Prediction of cross flow mixing in the structured packed bed through CFD simulation using (FBM and PMM) and validation with experiments journal October 2016
Combining PIV, POD and vortex identification algorithms for the study of unsteady turbulent swirling flows journal August 2001
Digital particle image velocimetry (DPIV) robust phase correlation journal April 2009
Assessment of advanced windowing techniques for digital particle image velocimetry (DPIV) journal June 2009
Uncertainty on PIV mean and fluctuating velocity due to bias and random errors journal February 2013
Estimation of uncertainty bounds for individual particle image velocimetry measurements from cross-correlation peak ratio journal April 2013
Collaborative framework for PIV uncertainty quantification: the experimental database journal June 2015
Collaborative framework for PIV uncertainty quantification: comparative assessment of methods journal June 2015
PIV uncertainty propagation journal June 2016
A comparative experimental evaluation of uncertainty estimation methods for two-component PIV journal August 2016
The Spectrum of Turbulence journal February 1938
Statistics of highly heterogeneous flow fields confined to three-dimensional random porous media journal January 2016
Impact of diffusion on transverse dispersion in two-dimensional ordered and random porous media journal June 2017
Prediction of the low-velocity distribution from the pore structure in simple porous media journal December 2017
Nonlocal Interface Dynamics and Pattern Formation in Gravity-Driven Unsaturated Flow through Porous Media journal December 2008
Flow Intermittency, Dispersion, and Correlated Continuous Time Random Walks in Porous Media journal May 2013
Pore-Scale Mixing and Transverse Dispersivity of Randomly Packed Monodisperse Spheres journal May 2013
Recent Mathematical Models for Turbulent Flow in Saturated Rigid Porous Media journal August 2001
A Macroscopic Turbulence Model for Flow in a Porous Medium journal June 1999
A Comparison Between Round Turbulent Jets and Particle-Laden Jets in Crossflow by Using Time-Resolved Stereoscopic Particle Image Velocimetry journal September 2011
Direct Numerical Simulation of Pebble Bed Flows: Database Development and Investigation of Low-Frequency Temporal Instabilities journal February 2017
Particle-Imaging Techniques For Experimental Fluid-Mechanics journal January 1991
The Proper Orthogonal Decomposition in the Analysis of Turbulent Flows journal January 1993
Experimental and Computational Assessment of Core Bypass Flow in Block-Type Very High Temperature Reactor journal August 2011
Low-dimensional procedure for the characterization of human faces journal January 1987

Figures / Tables (19)


Similar Records

Time-resolved PIV measurements in a low-aspect ratio facility of randomly packed spheres and flow analysis using modal decomposition
Journal Article · Sun Jul 15 20:00:00 EDT 2018 · Experiments in Fluids · OSTI ID:1571444

Experimental Measurements of the Wake of a Sphere at Subcritical Reynolds Numbers
Journal Article · Mon Feb 22 23:00:00 EST 2021 · Journal of Fluids Engineering · OSTI ID:1850579

Turbulent flow and vortex characteristics in a blocked subchannel of a helically wrapped rod bundle
Journal Article · Mon Jul 22 20:00:00 EDT 2019 · Experiments in Fluids · OSTI ID:1570696

Related Subjects