Interface Tracking Investigation of Geometric Effects on the Bubbly Flow in PWR Subchannels

Fang, Jun; Cambareri, Joseph J.; Rasquin, Michel; Gouws, Andre; Balakrishnan, Ramesh; Jansen, Kenneth E.; Bolotnov, Igor A.

doi:10.1080/00295639.2018.1499280

Interface Tracking Investigation of Geometric Effects on the Bubbly Flow in PWR Subchannels

Journal Article · Fri Aug 10 00:00:00 EDT 2018 · Nuclear Science and Engineering

DOI:https://doi.org/10.1080/00295639.2018.1499280· OSTI ID:1491828

^[1]; ^[2]; ^[3]; Gouws, Andre ^[2]; Balakrishnan, Ramesh ^[1]; ^[4]; ^[2]

Argonne National Lab. (ANL), Lemont, IL (United States)
North Carolina State Univ., Raleigh, NC (United States)
Cenaero, Gosselies (Belgium); Univ. of Colorado, Boulder, CO (United States)
Univ. of Colorado, Boulder, CO (United States)

We report that absorbing heat from the fuel rod surface, water as coolant can undergo subcooled boiling within a pressurized water reactor (PWR) fuel rod bundle. Because of the buoyancy effect, the vapor bubbles generated will then rise along and interact with the subchannel geometries. Reliable prediction of bubble behavior is of immense importance to ensure safe and stable reactor operation. However, given a complex engineering system like a nuclear reactor, it is very challenging (if not impossible) to conduct high-resolution measurements to study bubbly flows under reactor operation conditions. The lack of a fundamental two-phase-flow database is hindering the development of accurate two-phase-flow models required in more advanced reactor designs. In response to this challenge, first-principles–based numerical simulations are emerging as an attractive alternative to produce a complementary data source along with experiments. Leveraged by the unprecedented computing power offered by state-of-the-art supercomputers, direct numerical simulation (DNS), coupled with interface tracking methods, is becoming a practical tool to investigate some of the most challenging engineering flow problems. In the presented research, turbulent bubbly flow is simulated via DNS in single PWR subchannel geometries with auxiliary structures (e.g., supporting spacer grid and mixing vanes). The geometric effects these structures exert on the bubbly flow are studied with both a conventional time-averaging approach and a novel dynamic bubble tracking method. Lastly, the new insights obtained will help inform better two-phase models that can contribute to safer and more efficient nuclear reactor systems.

View Accepted Manuscript (DOE)

Research Organization:: Argonne National Lab. (ANL), Argonne, IL (United States)

Sponsoring Organization:: Argonne National Laboratory - Argonne Leadership Computing Facility - Early Science Program; USDOE Office of Nuclear Energy (NE). Consortium for Advanced Simulation of Light Water Reactors (CASL)

Grant/Contract Number:: AC02-06CH11357

OSTI ID:: 1491828

Journal Information:: Nuclear Science and Engineering, Journal Name: Nuclear Science and Engineering Journal Issue: 1-2 Vol. 193; ISSN 0029-5639

Publisher:: American Nuclear Society - Taylor & FrancisCopyright Statement

Country of Publication:: United States

Language:: English

References (35)

A stabilized finite element method for the incompressible Navier-Stokes equations using a hierarchical basis Whiting, Christian H.; Jansen, Kenneth E. International Journal for Numerical Methods in Fluids, Vol. 35, Issue 1 https://doi.org/10.1002/1097-0363(20010115)35:1<93::AID-FLD85>3.0.CO;2-G	journal	January 2001
A Level Set Approach for Computing Solutions to Incompressible Two-Phase Flow Sussman, Mark; Smereka, Peter; Osher, Stanley Journal of Computational Physics, Vol. 114, Issue 1 https://doi.org/10.1006/jcph.1994.1155	journal	September 1994
Direct Numerical Simulations of Multiphase Flows Tryggvason, G.; Fernández, A.; Esmaeeli, A. Turbulent Flow Computation https://doi.org/10.1007/0-306-48421-8_9	book	January 2002
Direct Numerical Simulations of Multiphase Flows Tryggvason, G.; Bunner, B.; Göz, M. F. Direct and Large-Eddy Simulation IV https://doi.org/10.1007/978-94-017-1263-7_60	book	January 2001
A theoretical basis for the Lockhart-Martinelli correlation for two-phase flow Chisholm, D. International Journal of Heat and Mass Transfer, Vol. 10, Issue 12 https://doi.org/10.1016/0017-9310(67)90047-6	journal	December 1967
Volume of fluid (VOF) method for the dynamics of free boundaries Hirt, C. W.; Nichols, B. D. Journal of Computational Physics, Vol. 39, Issue 1 https://doi.org/10.1016/0021-9991(81)90145-5	journal	January 1981
Fronts propagating with curvature-dependent speed: Algorithms based on Hamilton-Jacobi formulations Osher, Stanley; Sethian, James A. Journal of Computational Physics, Vol. 79, Issue 1 https://doi.org/10.1016/0021-9991(88)90002-2	journal	November 1988
A continuum method for modeling surface tension Brackbill, J. U.; Kothe, D. B.; Zemach, C. Journal of Computational Physics, Vol. 100, Issue 2 https://doi.org/10.1016/0021-9991(92)90240-Y	journal	June 1992
A front-tracking method for viscous, incompressible, multi-fluid flows Unverdi, Salih Ozen; Tryggvason, Grétar Journal of Computational Physics, Vol. 99, Issue 1 https://doi.org/10.1016/0021-9991(92)90294-9	journal	March 1992
A front-tracking method for viscous, incompressible, multi-fluid flows Unverdi, Salih Ozen; Tryggvason, Grétar Journal of Computational Physics, Vol. 100, Issue 1 https://doi.org/10.1016/0021-9991(92)90307-K	journal	May 1992
Computation of incompressible bubble dynamics with a stabilized finite element level set method Nagrath, Sunitha; Jansen, Kenneth E.; Lahey, Richard T. Computer Methods in Applied Mechanics and Engineering, Vol. 194, Issue 42-44 https://doi.org/10.1016/j.cma.2004.11.012	journal	October 2005
A physics based multiscale modeling of cavitating flows Ma, Jingsen; Hsiao, Chao-Tsung; Chahine, Georges L. Computers & Fluids, Vol. 145 https://doi.org/10.1016/j.compfluid.2016.12.010	journal	March 2017
Direct numerical simulations of flows with phase change Tryggvason, G.; Esmaeeli, A.; Al-Rawahi, N. Computers & Structures, Vol. 83, Issue 6-7 https://doi.org/10.1016/j.compstruc.2004.05.021	journal	February 2005
Detached direct numerical simulations of turbulent two-phase bubbly channel flow Bolotnov, Igor A.; Jansen, Kenneth E.; Drew, Donald A. International Journal of Multiphase Flow, Vol. 37, Issue 6 https://doi.org/10.1016/j.ijmultiphaseflow.2011.03.002	journal	July 2011
Evaluation of bubble-induced turbulence using direct numerical simulation Feng, Jinyong; Bolotnov, Igor A. International Journal of Multiphase Flow, Vol. 93 https://doi.org/10.1016/j.ijmultiphaseflow.2017.04.003	journal	July 2017
Modeling and simulation challenges pursued by the Consortium for Advanced Simulation of Light Water Reactors (CASL) Turinsky, Paul J.; Kothe, Douglas B. Journal of Computational Physics, Vol. 313 https://doi.org/10.1016/j.jcp.2016.02.043	journal	May 2016
Numerical simulation of flows in tight-lattice fuel bundles Merzari, E.; Ninokata, H.; Baglietto, E. Nuclear Engineering and Design, Vol. 238, Issue 7 https://doi.org/10.1016/j.nucengdes.2008.01.001	journal	July 2008
Interface tracking simulations of bubbly flows in PWR relevant geometries Fang, Jun; Rasquin, Michel; Bolotnov, Igor A. Nuclear Engineering and Design, Vol. 312 https://doi.org/10.1016/j.nucengdes.2016.07.002	journal	February 2017
Bubble tracking analysis of PWR two-phase flow simulations based on the level set method Fang, Jun; Bolotnov, Igor A. Nuclear Engineering and Design, Vol. 323 https://doi.org/10.1016/j.nucengdes.2017.07.034	journal	November 2017
Direct numerical simulation of reactor two-phase flows enabled by high-performance computing Fang, Jun; Cambareri, Joseph J.; Brown, Cameron S. Nuclear Engineering and Design, Vol. 330 https://doi.org/10.1016/j.nucengdes.2018.02.024	journal	April 2018
Statistical Mechanics of Fluid Mixtures Kirkwood, John G. The Journal of Chemical Physics, Vol. 3, Issue 5 https://doi.org/10.1063/1.1749657	journal	May 1935
On the Development of Multidimensional Two-Fluid Models for Vapor/Liquid Two-Phase Flows Lahey, R. T.; Drew, D. A. Chemical Engineering Communications, Vol. 118, Issue 1 https://doi.org/10.1080/00986449208936090	journal	November 1992
Scalable Implicit Flow Solver for Realistic Wing Simulations with Flow Control Rasquin, Michel; Smith, Cameron; Chitale, Kedar Computing in Science & Engineering, Vol. 16, Issue 6 https://doi.org/10.1109/MCSE.2014.75	journal	November 2014
Influence of Bubbles on the Turbulence Anisotropy Bolotnov, Igor A. Journal of Fluids Engineering, Vol. 135, Issue 5 https://doi.org/10.1115/1.4023651	journal	April 2013
Direct Numerical Simulation of Pebble Bed Flows: Database Development and Investigation of Low-Frequency Temporal Instabilities Fick, Lambert H.; Merzari, Elia; Hassan, Yassin A. Journal of Fluids Engineering, Vol. 139, Issue 5 https://doi.org/10.1115/1.4035300	journal	February 2017
Influence of Bubbles on the Turbulence Anisotropy Bolotnov, Igor A. ASME 2012 Fluids Engineering Division Summer Meeting collocated with the ASME 2012 Heat Transfer Summer Conference and the ASME 2012 10th International Conference on Nanochannels, Microchannels, and Minichannels, Volume 1: Symposia, Parts A and B https://doi.org/10.1115/fedsm2012-72412	conference	July 2013
Direct Numerical Simulations of Flows With Phase Change Tryggvason, Gretar; AlRawahi, Nabeel; Esmaeeli, Asghar ASME 2002 International Mechanical Engineering Congress and Exposition, Heat Transfer, Volume 2 https://doi.org/10.1115/imece2002-32823	conference	June 2008
Improving Unstructured Mesh Partitions for Multiple Criteria Using Mesh Adjacencies Smith, Cameron W.; Rasquin, Michel; Ibanez, Dan SIAM Journal on Scientific Computing, Vol. 40, Issue 1 https://doi.org/10.1137/15M1027814	journal	January 2018
New Simulation Schemes and Capabilities for the PHISICS/RELAP5-3D Coupled Suite Rabiti, C.; Alfonsi, A.; Epiney, A. Nuclear Science and Engineering, Vol. 182, Issue 1 https://doi.org/10.13182/NSE14-143	journal	January 2016
An Evaluation of the Departure from Nucleate Boiling in Bundles of Reactor Fuel Rods Tong, L. S. Nuclear Science and Engineering, Vol. 33, Issue 1 https://doi.org/10.13182/NSE68-A20912	journal	July 1968
Validation of the U.S. NRC Coupled Code System TRITON/TRACE/PARCS Using the Special Power Excursion Reactor Test III Wang, Raymond C.; Xu, Yunlin; Hudson, Nathanael Nuclear Technology, Vol. 183, Issue 3 https://doi.org/10.13182/NT13-A19437	journal	September 2013
Estimation of Shear-Induced Lift Force in Laminar and Turbulent Flows Thomas, Aaron M.; Fang, Jun; Feng, Jinyong Nuclear Technology, Vol. 190, Issue 3 https://doi.org/10.13182/NT14-72	journal	June 2015
Computational Methods for Multiphase flow Wulff, Wolfgang Multiphase Science and Technology, Vol. 5, Issue 1-4 https://doi.org/10.1615/multscientechn.v5.i1-4.30	journal	January 1990
The Fundamentals of the Statistical Theory of Turbulence Karman, Th. Von Journal of the Aeronautical Sciences, Vol. 4, Issue 4 https://doi.org/10.2514/8.350	journal	February 1937
Brief Review of Latest Direct Numerical Simulation on pool and film Boiling Kunugi, Tomoaki Nuclear Engineering and Technology, Vol. 44, Issue 8 https://doi.org/10.5516/NET.02.2012.717	journal	December 2012

Cited By (1)

Interface-Resolved Simulations of Reactor Flows Fang, Jun; Cambareri, Joseph J.; Li, Mengnan Nuclear Technology, Vol. 206, Issue 2 https://doi.org/10.1080/00295450.2019.1620056	journal	June 2019

Similar Records

Direct Numerical Simulation of the Turbulent Flow Through PWR Spacer Grid and Mixing Vanes

Journal Article · Sat Jul 01 00:00:00 EDT 2017 · Transactions of the American Nuclear Society · OSTI ID:23050421

Spacer Grid and Mixing Vanes Effects Study on Two-phase Flow Using Bubble Tracking Simulations

Journal Article · Fri Jul 01 00:00:00 EDT 2016 · Transactions of the American Nuclear Society · OSTI ID:23042888

Interface capturing simulations of bubble population effects in PWR subchannels

Journal Article · Mon Jun 08 20:00:00 EDT 2020 · Nuclear Engineering and Design · OSTI ID:1770592

Related Subjects

11 NUCLEAR FUEL CYCLE AND FUEL MATERIALS
22 GENERAL STUDIES OF NUCLEAR REACTORS
Bubble Tracking
DNS
Interface Tracking
Subchannel Geometry
Two-Phase Flow

Interface Tracking Investigation of Geometric Effects on the Bubbly Flow in PWR Subchannels

Citation Formats

References (35)

Cited By (1)

Similar Records

Related Subjects