The effect of cobalt doping on the morphology and electrochemical performance of high-voltage spinel LiNi0.5Mn1.5O4 cathode material
Abstract
In this paper, to reveal the effects of Co-doping on the electrochemical performance of micro-sized LiNi0.5Mn1.5O4 (LNMO), undoped LNMO and Co-doped LiCo0.1Ni0.45Mn1.45O4 (LCoNMO) are synthesized via a PVP-combustion method and calcined at 1000 °C for 6 h. SEM and XRD analyses suggest that Co-doping decreases the particle size and the LizNi1-zO2 impurity at the calcination temperature of 1000 °C. LCoNMO has much better rate capability while its specific capacity at C/5 is 10% lower than that of LNMO. At 15 C rate, their specific capacities are closed, and the LCoNMO delivers 86.2% capacity relative to C/5, and this value for LNMO is only 77.0%. The DLi + values determined by potential intermittent titration technique (PITT) test of LCoNMO are 1–2 times higher than that of LNMO in most SOC region. The LCoNMO shows very excellent cycling performance, which is the best value compared with literatures. After 1000 cycles, the LCoNMO still delivers 94.1% capacity. Finally, moreover, its coulombic efficiency and energy efficiency keep at 99.84% and over 97.3% during 1 C cycling, respectively.
- Authors:
-
- Zhengzhou Univ. (China). School of Materials Science and Engineering. International Joint Research Lab. for Low-Carbon & Environmental Materials of Henan Province; Lawrence Berkeley National Lab. (LBNL), Berkeley, CA (United States). Energy Storage and Distributed Resource Division. Energy Technologies Area
- Zhengzhou Univ. (China). School of Materials Science and Engineering. International Joint Research Lab. for Low-Carbon & Environmental Materials of Henan Province
- Lawrence Berkeley National Lab. (LBNL), Berkeley, CA (United States). Energy Storage and Distributed Resource Division. Energy Technologies Area
- Northeastern Univ., Shenyang (China). School of Materials and Metallurgy; Lawrence Berkeley National Lab. (LBNL), Berkeley, CA (United States). Energy Storage and Distributed Resource Division. Energy Technologies Area
- Publication Date:
- Research Org.:
- Lawrence Berkeley National Laboratory (LBNL), Berkeley, CA (United States)
- Sponsoring Org.:
- USDOE Office of Energy Efficiency and Renewable Energy (EERE), Vehicle Technologies Office (EE-3V); National Natural Science Foundation of China (NSFC); Fundamental Research Funds for the Central Universities of China; USDOE Office of Energy Efficiency and Renewable Energy (EERE), Office of Sustainable Transportation. Vehicle Technologies Office (VTO)
- OSTI Identifier:
- 1433095
- Alternate Identifier(s):
- OSTI ID: 1326447
- Grant/Contract Number:
- AC02-05CH11231; 51204038; U1504521; N110802002; L1502004
- Resource Type:
- Journal Article: Accepted Manuscript
- Journal Name:
- Solid State Ionics
- Additional Journal Information:
- Journal Volume: 292; Journal ID: ISSN 0167-2738
- Publisher:
- Elsevier
- Country of Publication:
- United States
- Language:
- English
- Subject:
- 36 MATERIALS SCIENCE; high-voltage spinel; lithium nickel manganese oxide; lithium chemical diffusion coefficient; cycling performance; rate performance
Citation Formats
Mao, Jing, Ma, Mengze, Liu, Panpan, Hu, Junhua, Shao, Guosheng, Battaglia, Vince, Dai, Kehua, and Liu, Gao. The effect of cobalt doping on the morphology and electrochemical performance of high-voltage spinel LiNi0.5Mn1.5O4 cathode material. United States: N. p., 2016.
Web. doi:10.1016/j.ssi.2016.05.008.
Mao, Jing, Ma, Mengze, Liu, Panpan, Hu, Junhua, Shao, Guosheng, Battaglia, Vince, Dai, Kehua, & Liu, Gao. The effect of cobalt doping on the morphology and electrochemical performance of high-voltage spinel LiNi0.5Mn1.5O4 cathode material. United States. https://doi.org/10.1016/j.ssi.2016.05.008
Mao, Jing, Ma, Mengze, Liu, Panpan, Hu, Junhua, Shao, Guosheng, Battaglia, Vince, Dai, Kehua, and Liu, Gao. 2016.
"The effect of cobalt doping on the morphology and electrochemical performance of high-voltage spinel LiNi0.5Mn1.5O4 cathode material". United States. https://doi.org/10.1016/j.ssi.2016.05.008. https://www.osti.gov/servlets/purl/1433095.
@article{osti_1433095,
title = {The effect of cobalt doping on the morphology and electrochemical performance of high-voltage spinel LiNi0.5Mn1.5O4 cathode material},
author = {Mao, Jing and Ma, Mengze and Liu, Panpan and Hu, Junhua and Shao, Guosheng and Battaglia, Vince and Dai, Kehua and Liu, Gao},
abstractNote = {In this paper, to reveal the effects of Co-doping on the electrochemical performance of micro-sized LiNi0.5Mn1.5O4 (LNMO), undoped LNMO and Co-doped LiCo0.1Ni0.45Mn1.45O4 (LCoNMO) are synthesized via a PVP-combustion method and calcined at 1000 °C for 6 h. SEM and XRD analyses suggest that Co-doping decreases the particle size and the LizNi1-zO2 impurity at the calcination temperature of 1000 °C. LCoNMO has much better rate capability while its specific capacity at C/5 is 10% lower than that of LNMO. At 15 C rate, their specific capacities are closed, and the LCoNMO delivers 86.2% capacity relative to C/5, and this value for LNMO is only 77.0%. The DLi + values determined by potential intermittent titration technique (PITT) test of LCoNMO are 1–2 times higher than that of LNMO in most SOC region. The LCoNMO shows very excellent cycling performance, which is the best value compared with literatures. After 1000 cycles, the LCoNMO still delivers 94.1% capacity. Finally, moreover, its coulombic efficiency and energy efficiency keep at 99.84% and over 97.3% during 1 C cycling, respectively.},
doi = {10.1016/j.ssi.2016.05.008},
url = {https://www.osti.gov/biblio/1433095},
journal = {Solid State Ionics},
issn = {0167-2738},
number = ,
volume = 292,
place = {United States},
year = {Fri Jun 03 00:00:00 EDT 2016},
month = {Fri Jun 03 00:00:00 EDT 2016}
}
Web of Science
Works referenced in this record:
A perspective on the high-voltage LiMn1.5Ni0.5O4 spinel cathode for lithium-ion batteries
journal, January 2014
- Manthiram, Arumugam; Chemelewski, Katharine; Lee, Eun-Sung
- Energy & Environmental Science, Vol. 7, Issue 4
An Advanced Lithium Ion Battery Based on High Performance Electrode Materials
journal, March 2011
- Hassoun, Jusef; Lee, Ki-Soo; Sun, Yang-Kook
- Journal of the American Chemical Society, Vol. 133, Issue 9
Research progress in high voltage spinel LiNi0.5Mn1.5O4 material
journal, September 2010
- Santhanam, R.; Rambabu, B.
- Journal of Power Sources, Vol. 195, Issue 17
Recent progress in high-voltage lithium ion batteries
journal, September 2013
- Hu, Meng; Pang, Xiaoli; Zhou, Zhen
- Journal of Power Sources, Vol. 237
Challenges and Approaches for High-Voltage Spinel Lithium-Ion Batteries
journal, May 2014
- Kim, Jung-Hyun; Pieczonka, Nicholas P. W.; Yang, Li
- ChemPhysChem, Vol. 15, Issue 10
Preparation and electrochemical investigation of LiMn2 − xMexO4 (Me: Ni, Fe, and x = 0.5, 1) cathode materials for secondary lithium batteries
journal, October 1997
- Amine, K.; Tukamoto, H.; Yasuda, H.
- Journal of Power Sources, Vol. 68, Issue 2
Synthesis and Electrochemistry of LiNi[sub x]Mn[sub 2−x]O[sub 4]
journal, January 1997
- Zhong, Qiming
- Journal of The Electrochemical Society, Vol. 144, Issue 1
Capacity fading reason of LiNi0.5Mn1.5O4 with commercial electrolyte
journal, December 2012
- Wu, Xianwen; Li, Xinhai; Wang, Zhixing
- Ionics, Vol. 19, Issue 2
Understanding the capacity fading mechanism in LiNi0.5Mn1.5O4/graphite Li-ion batteries
journal, February 2013
- Kim, Jung-Hyun; Pieczonka, Nicholas P. W.; Li, Zicheng
- Electrochimica Acta, Vol. 90
Studies of cycling behavior, ageing, and interfacial reactions of LiNi0.5Mn1.5O4 and carbon electrodes for lithium-ion 5-V cells
journal, November 2006
- Aurbach, Doron; Markovsky, Boris; Talyossef, Yosef
- Journal of Power Sources, Vol. 162, Issue 2
Synthesis and characterization of the metal-doped high-voltage spinel LiNi0.5Mn1.5O4 by mechanochemical process
journal, March 2008
- Oh, Si Hyoung; Jeon, Sang Hoon; Cho, Won Il
- Journal of Alloys and Compounds, Vol. 452, Issue 2
Recent developments in the doping of LiNi0.5Mn1.5O4 cathode material for 5 V lithium-ion batteries
journal, April 2011
- Yi, Ting-Feng; Xie, Ying; Ye, Ming-Fu
- Ionics, Vol. 17, Issue 5
Influence of chromium doping on the electrochemical performance of the 5V spinel cathode LiMn1.5Ni0.5O4
journal, September 2005
- Arunkumar, T. A.; Manthiram, A.
- Electrochimica Acta, Vol. 50, Issue 28
Electrochemical properties of LiNi0.5Mn1.5O4 cathode after Cr doping
journal, September 2006
- Park, Sung Bin; Eom, Won Sob; Cho, Won Il
- Journal of Power Sources, Vol. 159, Issue 1
Chromium doping as a new approach to improve the cycling performance at high temperature of 5V LiNi0.5Mn1.5O4-based positive electrode
journal, October 2008
- Aklalouch, Mohamed; Amarilla, José Manuel; Rojas, Rosa M.
- Journal of Power Sources, Vol. 185, Issue 1
Influence of Co substitution for Ni and Mn on the structural and electrochemical characteristics of LiNi0.5Mn1.5O4
journal, December 2008
- Ito, Atsushi; Li, Decheng; Lee, Yunsung
- Journal of Power Sources, Vol. 185, Issue 2
The role of particle size on the electrochemical properties at 25 and at 55°C of the LiCr0.2Ni0.4Mn1.4O4 spinel as 5V-cathode materials for lithium-ion batteries
journal, December 2009
- Aklalouch, Mohamed; Rojas, Rosa M.; Rojo, José María
- Electrochimica Acta, Vol. 54, Issue 28
Improved Electrochemical Performance of the 5 V Spinel Cathode LiMn[sub 1.5]Ni[sub 0.42]Zn[sub 0.08]O[sub 4] by Surface Modification
journal, January 2009
- Liu, J.; Manthiram, A.
- Journal of The Electrochemical Society, Vol. 156, Issue 1
Understanding the Improvement in the Electrochemical Properties of Surface Modified 5 V LiMn 1.42 Ni 0.42 Co 0.16 O 4 Spinel Cathodes in Lithium-ion Cells
journal, April 2009
- Liu, Jun; Manthiram, Arumugam
- Chemistry of Materials, Vol. 21, Issue 8
Structural and electrochemical investigations on the LiNi0.5−xMn1.5−yMx+yO4 (M=Cr, Al, Zr) compound for 5V cathode material
journal, February 2009
- Oh, Si Hyoung; Chung, Kyung Yoon; Jeon, Sang Hoon
- Journal of Alloys and Compounds, Vol. 469, Issue 1-2
Effects of Co doping on Li[Ni0.5CoxMn1.5−x]O4 spinel materials for 5V lithium secondary batteries via Co-precipitation
journal, April 2009
- Oh, Sung Woo; Myung, Seung-Taek; Kang, Han Byeol
- Journal of Power Sources, Vol. 189, Issue 1
Enhancements of rate capability and cyclic performance of spinel LiNi0.5Mn1.5O4 by trace Ru-doping
journal, July 2009
- Wang, Hailong; Xia, Hui; Lai, Man On
- Electrochemistry Communications, Vol. 11, Issue 7
Sub-micrometric LiCr0.2Ni0.4Mn1.4O4 spinel as 5V-cathode material exhibiting huge rate capability at 25 and 55°C
journal, April 2010
- Aklalouch, Mohamed; Amarilla, José Manuel; Rojas, Rosa M.
- Electrochemistry Communications, Vol. 12, Issue 4
Rate Properties and Elevated-Temperature Performances of LiNi[sub 0.5−x]Cr[sub 2x]Mn[sub 1.5−x]O[sub 4] (0≤2x≤0.8) as 5 V Cathode Materials for Lithium-Ion Batteries
journal, January 2010
- Liu, Dongqiang; Lu, Yuhao; Goodenough, John B.
- Journal of The Electrochemical Society, Vol. 157, Issue 11
Synthesis of pure phase disordered LiMn1.45Cr0.1Ni0.45O4 by a post-annealing method
journal, November 2012
- Liu, D.; Hamel-Paquet, J.; Trottier, J.
- Journal of Power Sources, Vol. 217, p. 400-406
Role of Cation Ordering and Surface Segregation in High-Voltage Spinel LiMn 1.5 Ni 0.5– x M x O 4 (M = Cr, Fe, and Ga) Cathodes for Lithium-Ion Batteries
journal, September 2012
- Shin, Dong Wook; Bridges, Craig A.; Huq, Ashfia
- Chemistry of Materials, Vol. 24, Issue 19
Electrochemical investigations of the LiNi0.45M0.10Mn1.45O4 (M=Fe, Co, Cr) 5V cathode materials for lithium ion batteries
journal, May 2012
- Zhong, G. B.; Wang, Y. Y.; Yu, Y. Q.
- Journal of Power Sources, Vol. 205
Improving the rate capability of high voltage lithium-ion battery cathode material LiNi0.5Mn1.5O4 by ruthenium doping
journal, December 2014
- Kiziltas-Yavuz, Nilüfer; Bhaskar, Aiswarya; Dixon, Ditty
- Journal of Power Sources, Vol. 267
Improved cycling and rate performance of Sm-doped LiNi0.5Mn1.5O4 cathode materials for 5V lithium ion batteries
journal, January 2014
- Mo, Mingyue; Hui, K. S.; Hong, Xiaoting
- Applied Surface Science, Vol. 290
Syntheses and electrochemical properties of the Na-doped LiNi0.5Mn1.5O4 cathode materials for lithium-ion batteries
journal, November 2014
- Wang, Jing; Lin, Weiqing; Wu, Bihe
- Electrochimica Acta, Vol. 145
Influence of annealing temperature on the electrochemical and surface properties of the 5-V spinel cathode material LiCr0.2Ni0.4Mn1.4O4 synthesized by a sol–gel technique
journal, April 2014
- Younesi, Reza; Malmgren, Sara; Edström, Kristina
- Journal of Solid State Electrochemistry, Vol. 18, Issue 8
LiNi0.5Mn1.5O3.975F0.05 as novel 5V cathode material
journal, December 2007
- Xu, X. X.; Yang, J.; Wang, Y. Q.
- Journal of Power Sources, Vol. 174, Issue 2
Effect of sulfur and nickel doping on morphology and electrochemical performance of LiNi0.5Mn1.5O4−xSx spinel material in 3-V region
journal, October 2006
- Sun, Yang-Kook; Oh, Sung Woo; Yoon, Chong Seung
- Journal of Power Sources, Vol. 161, Issue 1
Electrochemical studies of spinel LiNi0.5Mn1.5O4 cathodes with different particle morphologies
journal, February 2012
- Mao, Jing; Dai, Kehua; Zhai, Yuchun
- Electrochimica Acta, Vol. 63
A New Lithium Cathode LiCoMnO[sub 4]: Toward Practical 5 V Lithium Batteries
journal, January 1999
- Kawai, Hiroo
- Electrochemical and Solid-State Letters, Vol. 1, Issue 5
5 V lithium cathodes based on spinel solid solutions Li2Co1+XMn3−XO8: -1≤X≤1
journal, September 1999
- Kawai, Hiroo; Nagata, Mikito; Kageyama, Hiroyuki
- Electrochimica Acta, Vol. 45, Issue 1-2
High-Voltage LiNi 1/2 Mn 3/2 O 4 Spinel: Cationic Order and Particle Size Distribution
journal, November 2011
- Ivanova, Svetlana; Zhecheva, Ekaterina; Stoyanova, Radostina
- The Journal of Physical Chemistry C, Vol. 115, Issue 50
Composition-Structure Relationships in the Li-Ion Battery Electrode Material LiNi 0.5 Mn 1.5 O 4
journal, August 2012
- Cabana, Jordi; Casas-Cabanas, Montserrat; Omenya, Fredrick O.
- Chemistry of Materials, Vol. 24, Issue 15
Structure and insertion properties of disordered and ordered LiNi0.5Mn1.5O4 spinels prepared by wet chemistry
journal, June 2006
- Amdouni, N.; Zaghib, K.; Gendron, F.
- Ionics, Vol. 12, Issue 2
A comparative study of Fd-3m and P4332 “LiNi0.5Mn1.5O4”
journal, June 2011
- Wang, Liping; Li, Hong; Huang, Xuejie
- Solid State Ionics, Vol. 193, Issue 1
Structural and electrochemical characteristics of LiNi0.5−xCo2xMn1.5−xO4 prepared by spray drying process and post-annealing in O2
journal, October 2006
- Li, Decheng; Ito, Atsushi; Kobayakawa, Koichi
- Journal of Power Sources, Vol. 161, Issue 2
Comparative Study of LiNi 0.5 Mn 1.5 O 4 - δ and LiNi 0.5 Mn 1.5 O 4 Cathodes Having Two Crystallographic Structures: Fd 3̄ m and P 4 3 32
journal, March 2004
- Kim, J. -H.; Myung, S. -T.; Yoon, C. S.
- Chemistry of Materials, Vol. 16, Issue 5
Thermodynamic and Mass Transport Properties of “LiAl”
journal, January 1979
- Wen, C. John
- Journal of The Electrochemical Society, Vol. 126, Issue 12
The effect of particle surface facets on the kinetic properties of LiMn 1.5 Ni 0.5 O 4 cathode materials
journal, January 2013
- Hai, Bin; Shukla, Alpesh K.; Duncan, Hugues
- J. Mater. Chem. A, Vol. 1, Issue 3
Works referencing / citing this record:
Understanding structural, optical, magnetic and electrical performances of Fe- or Co-substituted spinel LiMn1.5Ni0.5O4 cathode materials
journal, January 2019
- Sanad, M. M. S.; Abdellatif, H. A.; Elnaggar, Elsayed M.
- Applied Physics A, Vol. 125, Issue 2
Effects of LiBF4 concentration in carbonate-based electrolyte on the stability of high-voltage LiNi0.5Mn1.5O4 cathode
journal, March 2019
- Feng, Yaohua; Xu, Hui; Zhang, Yu
- Ionics, Vol. 25, Issue 8
P2-type Na 2/3 Ni 1/3 Mn 2/3 O 2 Cathode Material with Excellent Rate and Cycling Performance for Sodium-Ion Batteries
journal, January 2019
- Mao, Jing; Liu, Xin; Liu, Jianwen
- Journal of The Electrochemical Society, Vol. 166, Issue 16