Enhanced pozzolanic reactivity in hydrogen-form zeolites as supplementary cementitious materials

Tuinukuafe, Atolo Aaron; Rademacher, David X.; Nenoff, Tina M.; Rimsza, Jessica M.

doi:10.1016/j.cemconcomp.2024.105790

Title: Enhanced pozzolanic reactivity in hydrogen-form zeolites as supplementary cementitious materials

Journal Article · 02 October 2024 · Cement and Concrete Composites

DOI: https://doi.org/10.1016/j.cemconcomp.2024.105790 · OSTI ID:2476628

Tuinukuafe, Atolo Aaron ^[1]; Rademacher, David X. ^[1]; Nenoff, Tina M. ^[1];

^[1]

Sandia National Lab. (SNL-NM), Albuquerque, NM (United States)

Pozzolans rich in silica and alumina react with lime to form cementing compounds and are incorporated into portland cement as supplementary cementitious materials (SCMs). However, pozzolanic reactions progress slower than portland cement hydration, limiting their use in modern construction due to insufficient early-age strength. Hence, alternative SCMs that enable faster pozzolanic reactions are necessary including synthetic zeolites, which have high surface areas and compositional purity that indicate the possibility of rapid pozzolanic reactivity. Synthetic zeolites with varying cation composition (Na-zeolite, H-zeolite), SiO₂/Al₂O₃ ratio, and framework type were evaluated for pozzolanic reactivity via Ca(OH)₂ consumption using ion exchange and in-situ X-ray diffraction experiments. Na-zeolites exhibited limited exchange reactions with KOH and Ca(OH)₂ due to the occupancy of acid sites by Na⁺ and hydroxyl groups. Meanwhile, H-zeolites readily adsorbed K⁺ and Ca²⁺ from a hydroxide solution by exchanging cations with H⁺ at Brønsted acid sites or cation adsorption at vacant acid sites. By adsorbing cations, the H-zeolite reduced the pH and increased Ca²⁺ solubility to promote pozzolanic reactions in a system where Ca(OH)₂ dissolution/diffusion was a rate limiting factor. High H-zeolite reactivity resulted in 0.8 g of Ca(OH)₂ consumed per 1 g of zeolites after 16 h of reaction versus 0.4 g of Ca(OH)₂ consumed per 1 g of Na-zeolite. The H-zeolite modulated the pore fluid alkalinity and created a low-density amorphous silicate phase via mechanisms analogous to two-step C-S-H nucleation experiments. Finally, controlling these reaction mechanisms is key to developing next generation pozzolanic cementitious systems with comparable hydration rates to portland cement.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Sandia National Laboratories (SNL-NM), Albuquerque, NM (United States)

Sponsoring Organization:: USDOE Laboratory Directed Research and Development (LDRD) Program; USDOE National Nuclear Security Administration (NNSA)

Grant/Contract Number:: NA0003525

OSTI ID:: 2476628

Report Number(s):: SAND--2024-15188J

Journal Information:: Cement and Concrete Composites, Journal Name: Cement and Concrete Composites Vol. 154; ISSN 0958-9465

Publisher:: ElsevierCopyright Statement

Country of Publication:: United States

Language:: English

References (54)

Zeolite from fly ash: synthesis and characterization Ojha, Keka; Pradhan, Narayan C.; Samanta, Amar Nath Bulletin of Materials Science, Vol. 27, Issue 6 https://doi.org/10.1007/BF02707285	journal	December 2004
Calorimetric evolution of the early pozzolanic reaction of natural zeolites Snellings, R.; Mertens, G.; Elsen, J. Journal of Thermal Analysis and Calorimetry, Vol. 101, Issue 1 https://doi.org/10.1007/s10973-009-0449-x	journal	September 2009
Alkalies in cement: A review Jawed, Inam; Skalny, Jan Cement and Concrete Research, Vol. 8, Issue 1 https://doi.org/10.1016/0008-8846(78)90056-X	journal	January 1978
A trimethylsilylation study of tricalcium silicate pastes Mohan, K.; Taylor, H. F. W. Cement and Concrete Research, Vol. 12, Issue 1 https://doi.org/10.1016/0008-8846(82)90095-3	journal	January 1982
Formation and carbonation of C-S-H in water Suzuki, Kazutaka; Nishikawa, Tadahiro; Ito, Suketoshi Cement and Concrete Research, Vol. 15, Issue 2 https://doi.org/10.1016/0008-8846(85)90032-8	journal	March 1985
On the reaction of C-S-H(di, poly) with alkali hydroxides Stade, H. Cement and Concrete Research, Vol. 19, Issue 5 https://doi.org/10.1016/0008-8846(89)90051-3	journal	September 1989
On the intermediates in zeolite Y synthesis Fahlke, B.; Starke, P.; Seefeld, V. Zeolites, Vol. 7, Issue 3 https://doi.org/10.1016/0144-2449(87)90052-2	journal	May 1987
Kinetics of zeolite dissolution: Part 3. Dissolution of synthetic mordenite in hot sodium hydroxide solutions Čiẑmek, Ankica; Komunjer, Ljepša; Subotić, Boris Zeolites, Vol. 12, Issue 2 https://doi.org/10.1016/0144-2449(92)90083-2	journal	February 1992
A physicochemical study of the againg of colloidal silica gels used in zeolite Y synthesis Ginter, D. M.; Went, G. T.; Bell, A. T. Zeolites, Vol. 12, Issue 6 https://doi.org/10.1016/0144-2449(92)90125-9	journal	July 1992
Proposed mechanism of C-S-H growth tested by soft X-ray microscopy Gartner, E. M.; Kurtis, K. E.; Monteiro, P. J. M. Cement and Concrete Research, Vol. 30, Issue 5 https://doi.org/10.1016/S0008-8846(00)00235-0	journal	May 2000
Estimating the electrical conductivity of cement paste pore solutions from OH−, K+ and Na+ concentrations Snyder, K. A.; Feng, X.; Keen, B. D. Cement and Concrete Research, Vol. 33, Issue 6 https://doi.org/10.1016/S0008-8846(02)01068-2	journal	June 2003
Zeolitic tuffs of Kimolos Island, Aegean Sea, Greece and their industrial potential Fragoulis, Dimitrios; Chaniotakis, Emmanuel; Stamatakis, Michael G. Cement and Concrete Research, Vol. 27, Issue 6 https://doi.org/10.1016/S0008-8846(97)00072-0	journal	June 1997
Synthesis of zeolites from coal fly ash: an overview Querol, X.; Moreno, N.; Umaña, J. C. International Journal of Coal Geology, Vol. 50, Issue 1-4 https://doi.org/10.1016/S0166-5162(02)00124-6	journal	May 2002
A virtual rapid chloride permeability test Bentz, Dale P. Cement and Concrete Composites, Vol. 29, Issue 10 https://doi.org/10.1016/j.cemconcomp.2007.06.006	journal	November 2007
Milling as a pretreatment method for increasing the reactivity of natural zeolites for use as supplementary cementitious materials Burris, Lisa E.; Juenger, Maria C. G. Cement and Concrete Composites, Vol. 65 https://doi.org/10.1016/j.cemconcomp.2015.09.008	journal	January 2016
Examining the pozzolanicity of supplementary cementitious materials using isothermal calorimetry and thermogravimetric analysis Suraneni, Prannoy; Weiss, Jason Cement and Concrete Composites, Vol. 83 https://doi.org/10.1016/j.cemconcomp.2017.07.009	journal	October 2017
Estimating reaction kinetics of cementitious pastes containing fly ash Glosser, Deborah; Suraneni, Prannoy; Isgor, O. Burkan Cement and Concrete Composites, Vol. 112 https://doi.org/10.1016/j.cemconcomp.2020.103655	journal	September 2020
Using glass content to determine the reactivity of fly ash for thermodynamic calculations Glosser, Deborah; Suraneni, Prannoy; Isgor, O. Burkan Cement and Concrete Composites, Vol. 115 https://doi.org/10.1016/j.cemconcomp.2020.103849	journal	January 2021
Effects of unconventional fly ashes on cementitious paste properties Wang, Ying; Burris, Lisa; Hooton, R. Douglas Cement and Concrete Composites, Vol. 125 https://doi.org/10.1016/j.cemconcomp.2021.104291	journal	January 2022
Impact of metakaolin content and fineness on the behavior of calcined clay blended cements admixed with HPEG PCE superplasticizer Li, Ran; Lei, Lei; Plank, Johann Cement and Concrete Composites, Vol. 133 https://doi.org/10.1016/j.cemconcomp.2022.104654	journal	October 2022
Characterization and quantification of the pozzolanic reactivity of natural and non-conventional pozzolans Yoon, Jinyoung; Jafari, Khashayar; Tokpatayeva, Raikhan Cement and Concrete Composites, Vol. 133 https://doi.org/10.1016/j.cemconcomp.2022.104708	journal	October 2022
Enhancing physiochemical properties and reactivity of landfilled fly ash through thermo-mechanical beneficiation Shakouri, Mahmoud; Teymouri, Mohammad; Vaddey, Naga Pavan Cement and Concrete Composites, Vol. 144 https://doi.org/10.1016/j.cemconcomp.2023.105310	journal	November 2023
Solubility and structure of calcium silicate hydrate Chen, Jeffrey J.; Thomas, Jeffrey J.; Taylor, Hal F. W. Cement and Concrete Research, Vol. 34, Issue 9 https://doi.org/10.1016/j.cemconres.2004.04.034	journal	September 2004
Pozzolanic reactions of common natural zeolites with lime and parameters affecting their reactivity Mertens, G.; Snellings, R.; Van Balen, K. Cement and Concrete Research, Vol. 39, Issue 3 https://doi.org/10.1016/j.cemconres.2008.11.008	journal	March 2009
Early age hydration and pozzolanic reaction in natural zeolite blended cements: Reaction kinetics and products by in situ synchrotron X-ray powder diffraction Snellings, R.; Mertens, G.; Cizer, Ö. Cement and Concrete Research, Vol. 40, Issue 12 https://doi.org/10.1016/j.cemconres.2010.08.012	journal	December 2010
Mechanisms of cement hydration Bullard, Jeffrey W.; Jennings, Hamlin M.; Livingston, Richard A. Cement and Concrete Research, Vol. 41, Issue 12 https://doi.org/10.1016/j.cemconres.2010.09.011	journal	December 2011
A remastered external standard method applied to the quantification of early OPC hydration Jansen, Daniel; Goetz-Neunhoeffer, Friedlinde; Stabler, Christopher Cement and Concrete Research, Vol. 41, Issue 6 https://doi.org/10.1016/j.cemconres.2011.03.004	journal	June 2011
Quantitative analysis of C–S–H in hydrating alite pastes by in-situ XRD Bergold, S. T.; Goetz-Neunhoeffer, F.; Neubauer, J. Cement and Concrete Research, Vol. 53 https://doi.org/10.1016/j.cemconres.2013.06.001	journal	November 2013
Investigation of the carbonation mechanism of CH and C-S-H in terms of kinetics, microstructure changes and moisture properties Morandeau, A.; Thiéry, M.; Dangla, P. Cement and Concrete Research, Vol. 56 https://doi.org/10.1016/j.cemconres.2013.11.015	journal	February 2014
The effect of acid treatment on the reactivity of natural zeolites used as supplementary cementitious materials Burris, Lisa E.; Juenger, Maria C. G. Cement and Concrete Research, Vol. 79 https://doi.org/10.1016/j.cemconres.2015.08.007	journal	January 2016
Performance of high-volume fly ash concrete in marine environment Moffatt, Edward G.; Thomas, Michael D. A.; Fahim, Andrew Cement and Concrete Research, Vol. 102 https://doi.org/10.1016/j.cemconres.2017.09.008	journal	December 2017
Stability of hemicarbonate under cement paste-like conditions Georget, Fabien; Lothenbach, Barbara; Wilson, William Cement and Concrete Research, Vol. 153 https://doi.org/10.1016/j.cemconres.2021.106692	journal	March 2022
Enhanced alite dissolution by CAH10 addition Becker, Franz; Goetz-Neunhoeffer, Friedlinde; Neubauer, Jürgen Cement and Concrete Research, Vol. 164 https://doi.org/10.1016/j.cemconres.2022.107051	journal	February 2023
Investigations on the effect of alkalis on C-S-H growth rates and their impact on early C3S hydration rates Wagner, D.; Bellmann, F.; Neubauer, J. Cement and Concrete Research, Vol. 173 https://doi.org/10.1016/j.cemconres.2023.107268	journal	November 2023
High early pozzolanic reactivity of alumina-silica gel: A study of the hydration of composite cements with carbonated recycled concrete paste Zajac, Maciej; Song, Jiayi; Ullrich, Patrick Cement and Concrete Research, Vol. 175 https://doi.org/10.1016/j.cemconres.2023.107345	journal	January 2024
Influence of the availability of calcium hydroxide, sulphates, and alkalis on hydration of supplementary cementitious materials Parashar, Anuj; Bishnoi, Shashank Cement and Concrete Research, Vol. 175 https://doi.org/10.1016/j.cemconres.2023.107388	journal	January 2024
Studying effects of chemical admixtures on the workability retention of zeolitic Portland cement mortar AzariJafari, Hessam; Kazemian, Ali; Ahmadi, Babak Construction and Building Materials, Vol. 72 https://doi.org/10.1016/j.conbuildmat.2014.09.020	journal	December 2014
Predicting the degree of reaction of supplementary cementitious materials in cementitious pastes using a pozzolanic test Ramanathan, Sivakumar; Moon, Hoon; Croly, Michael Construction and Building Materials, Vol. 204 https://doi.org/10.1016/j.conbuildmat.2019.01.173	journal	April 2019
Sulfuric acid improves the reactivity of zeolites via dealumination Chen, Xu; Srubar, Wil V. Construction and Building Materials, Vol. 264 https://doi.org/10.1016/j.conbuildmat.2020.120648	journal	December 2020
Evaluation and beneficiation of high sulfur and high alkali fly ashes for use as supplementary cementitious materials in concrete Kaladharan, Gopakumar; Rajabipour, Farshad Construction and Building Materials, Vol. 339 https://doi.org/10.1016/j.conbuildmat.2022.127672	journal	July 2022
Natural carbonation of portland cement with synthetic zeolite Y as a supplementary cementitious material Tuinukuafe, Atolo A.; Mills, Melissa M.; Walder, Brennan J. Construction and Building Materials, Vol. 425 https://doi.org/10.1016/j.conbuildmat.2024.136068	journal	April 2024
The zeolite–lime pozzolanic reaction: Reaction kinetics and products by in situ synchrotron X-ray powder diffraction Snellings, Ruben; Mertens, Gilles; Hertsens, Sam Microporous and Mesoporous Materials, Vol. 126, Issue 1-2 https://doi.org/10.1016/j.micromeso.2009.05.017	journal	November 2009
Two-Step Nucleation Process of Calcium Silicate Hydrate, the Nanobrick of Cement Krautwurst, Nina; Nicoleau, Luc; Dietzsch, Michael Chemistry of Materials, Vol. 30, Issue 9 https://doi.org/10.1021/acs.chemmater.7b04245	journal	April 2018
Near-term pathways for decarbonizing global concrete production Olsson, Josefine A.; Miller, Sabbie A.; Alexander, Mark G. Nature Communications, Vol. 14, Issue 1 https://doi.org/10.1038/s41467-023-40302-0	journal	July 2023
Multi-step nucleation pathway of C-S-H during cement hydration from atomistic simulations Aretxabaleta, Xabier M.; López-Zorrilla, Jon; Etxebarria, Iñigo Nature Communications, Vol. 14, Issue 1 https://doi.org/10.1038/s41467-023-43500-y	journal	December 2023
Carbon Capture and Utilization by mineralization of cement pastes derived from recycled concrete Skocek, Jan; Zajac, Maciej; Ben Haha, Mohsen Scientific Reports, Vol. 10, Issue 1 https://doi.org/10.1038/s41598-020-62503-z	journal	March 2020
The Filler Effect: The Influence of Filler Content and Surface Area on Cementitious Reaction Rates Oey, Tandré; Kumar, Aditya; Bullard, Jeffrey W. Journal of the American Ceramic Society, Vol. 96, Issue 6 https://doi.org/10.1111/jace.12264	journal	March 2013
Understanding the Filler Effect on the Nucleation and Growth of C-S-H Berodier, E.; Scrivener, K. Journal of the American Ceramic Society, Vol. 97, Issue 12 https://doi.org/10.1111/jace.13177	journal	August 2014
Comparative Study of the Reactivity and Performance of Different Nontraditional and Natural Pozzolans in Cementitious System Tokpatayeva, R.; Castillo, A.; Yoon, J. Advances in Civil Engineering Materials, Vol. 11, Issue 2 https://doi.org/10.1520/ACEM20220021	journal	November 2022
Report of RILEM TC 267-TRM phase 2: optimization and testing of the robustness of the R3 reactivity tests for supplementary cementitious materials Avet, François; Li, Xuerun; Ben Haha, Mohsen Materials and Structures, Vol. 55, Issue 3 https://doi.org/10.1617/s11527-022-01928-6	journal	March 2022
A method for predicting alkazi ion concentrations in cement pore solutions Taylor, H. F. W. Advances in Cement Research, Vol. 1, Issue 1 https://doi.org/10.1680/adcr.1987.1.1.5	journal	October 1987
Use of pore solution analysis in design for concrete durability Hooton, R. D.; Thomas, M. D. A.; Ramlochan, T. Advances in Cement Research, Vol. 22, Issue 4 https://doi.org/10.1680/adcr.2010.22.4.203	journal	October 2010
Lessons from a lost technology: The secrets of Roman concrete Elsen, J.; Cizer, O.; Snellings, R. American Mineralogist, Vol. 98, Issue 11-12 https://doi.org/10.2138/am.2013.4643	journal	November 2013
Classification and Milling Increase Fly Ash Pozzolanic Reactivity Snellings, Ruben; Kazemi-Kamyab, Hadi; Nielsen, Peter Frontiers in Built Environment, Vol. 7 https://doi.org/10.3389/fbuil.2021.670996	journal	April 2021

Similar Records

Early age hydration and pozzolanic reaction in natural zeolite blended cements: Reaction kinetics and products by in situ synchrotron X-ray powder diffraction

Journal Article · 2010 · Cement and Concrete Research · OSTI ID:21418098

Snellings, R; Mertens, G; Cizer, O; +1 more

Natural carbonation of portland cement with synthetic zeolite Y as a supplementary cementitious material

Journal Article · 2024 · Construction and Building Materials · OSTI ID:2430102

Tuinukuafe, Atolo Aaron; Mills, Melissa Marie; Walder, Brennan J.; +7 more

Sulfuric Acid Improves the Reactivity of Zeolites via Dealumination

Journal Article · 2020 · Construction and Building Materials · OSTI ID:1718916

Chen, Xu; Srubar, III, Wil V.

Related Subjects

36 MATERIALS SCIENCE
C-S-H
Ion-exchange
Pozzolans
Reactivity
Supplementary cementitious materials (SCMs)
Zeolites

Title: Enhanced pozzolanic reactivity in hydrogen-form zeolites as supplementary cementitious materials

Citation Formats

References (54)

Similar Records

Related Subjects