Controlled dehumidification to extract clean water from a multicomponent gaseous mixture of organic contaminants

Journal Article · 30 July 2021 · Journal of Water Process Engineering

DOI: https://doi.org/10.1016/j.jwpe.2021.102229 · OSTI ID:1977412

Nikooei, Elnaz ^[1]; AuYeung, Nick ^[2]; Zhang, Xiang ^[2]; Goulas, Konstantinos ^[2]; Abbasi, Behrooz ^[3]; Dyall, Alexander ^[2]; Abbasi, Bahman ^[2]

---

1. Oregon State Univ., Corvallis, OR (United States); OSTI
2. Oregon State Univ., Corvallis, OR (United States)
3. Univ. of Nevada, Reno, NV (United States)

Rapid expansion of the unconventional oil and gas extraction has increased American energy independence, but also led to increased production of large amounts of contaminated water. Wastewater from the oil and gas industry contains a wide range of contaminants. Injecting such contaminated water into disposal wells or discharging it to the environment jeopardizes freshwater resources. Conventional and membrane-based wastewater treatment techniques are often not effective choices to treat highly contaminated wastewater; however, a suitable way to remove contaminants from wastewater is to selectively separate water in a process analogous to humidification-dehumidification (HDH). Only a few studies have investigated the use of HDH for wastewater treatment. In this study, a novel HDH system is introduced for treating highly contaminated water, such as oil and gas flowback and produced water. In this HDH process, a non-condensable gas, such as air, mixes with wastewater vapor to facilitate the separation of contaminants. As a result, clean water condenses from the multicomponent gaseous mixture while air carries organic contaminants out of the dehumidification section. A laboratory apparatus was constructed and experiments were performed to investigate the HDH process for wastewater treatment and to study the effects of flow dynamics including air flow rate on the composition of treated water. Different contaminants including benzene, toluene, 2-propanol and 2-butoxyethanol were tested. Experimental results showed that the system can be successfully applied for removing volatile and/or toxic organic contaminants from wastewater. A representative multicomponent mixture of fracking wastewater was successfully treated using the experimental setup and clean water with quality of 98.3% was obtained. It was revealed that increasing the air-to-vapor mass ratio improves purity of treated water. Quantitative analysis showed that by increasing the air-to-vapor mass ratio from 0.6 to 5.9, the fraction of separated 2-propanol through the air was improved from 43% to more than 96% of the initial amount. ASPEN software was employed to simulate equilibrium conditions. Finally, experimental results were observed to have lower mass fraction of residual contaminant in the treated water compared to equilibrium state.

• Research Organization: Oregon State Univ., Corvallis, OR (United States)
• Sponsoring Organization: USDOE Advanced Research Projects Agency - Energy (ARPA-E)
• Grant/Contract Number: AR0001000
• OSTI ID: 1977412
• Journal Information: Journal of Water Process Engineering, Journal Name: Journal of Water Process Engineering Journal Issue: C Vol. 43; ISSN 2214-7144
• Publisher: ElsevierCopyright Statement
• Country of Publication: United States
• Language: English