Oxygen and relative humidity monitoring with films tailored for enhanced photoluminescence
Abstract
In this study, approaches to generate porous or doped sensing films, which significantly enhance the photoluminescence (PL) of oxygen optical sensors, and thus improve the signal-to-noise (S/N) ratio, are presented. Tailored films, which enable monitoring the relative humidity (RH) as well, are also presented. Effective porous structures, in which the O2-sensitive dye Pt octaethylporphyrin (PtOEP) or the Pd analog PdOEP was embedded, were realized by first generating blend films of polyethylene glycol (PEG) with polystyrene (PS) or with ethyl cellulose (EC), and then immersing the dried films in water to remove the water-soluble PEG. This approach creates pores (voids) in the sensing films. The dielectric contrast between the films’ constituents and the voids increases photon scattering, which in turn increases the optical path of the excitation light within the film, and hence light absorption by the dye, and its PL. Optimized sensing films with a PEG:PS ratio of 1:4 (PEG’s molecular weight Mw ~8000) led to ~4.4× enhancement in the PL (in comparison to PS films). Lower Mw ~200 PEG with a PEG:EC ratio of 1:1 led to a PL enhancement of ~4.7×. Film-dependent PL enhancements were observed at all oxygen concentrations. The strong PL enhancement enables (i) using lowermore »
- Authors:
-
- Ames Lab., Ames, IA (United States)
- Ames Lab., Ames, IA (United States); Iowa State Univ., Ames, IA (United States)
- Iowa State Univ., Ames, IA (United States)
- Publication Date:
- Research Org.:
- Ames Lab., Ames, IA (United States)
- Sponsoring Org.:
- USDOE Office of Science (SC), Basic Energy Sciences (BES)
- OSTI Identifier:
- 1225526
- Alternate Identifier(s):
- OSTI ID: 1355053
- Report Number(s):
- IS-J-8536
Journal ID: ISSN 0003-2670; PII: S0003267014012902
- Grant/Contract Number:
- AC02-07CH11358; AC 02-07CH11358
- Resource Type:
- Accepted Manuscript
- Journal Name:
- Analytica Chimica Acta
- Additional Journal Information:
- Journal Volume: 853; Journal Issue: C; Journal ID: ISSN 0003-2670
- Publisher:
- Elsevier
- Country of Publication:
- United States
- Language:
- English
- Subject:
- 47 OTHER INSTRUMENTATION; O2 sensor; porous sensing films; photoluminescence enhancement; light scattering; relative humidity effect
Citation Formats
Cui, Weipan, Liu, Rui, Manna, Eeshita, Park, Joong -Mok, Fungura, Fadzai, Shinar, Joseph, and Shinar, Ruth. Oxygen and relative humidity monitoring with films tailored for enhanced photoluminescence. United States: N. p., 2014.
Web. doi:10.1016/j.aca.2014.10.035.
Cui, Weipan, Liu, Rui, Manna, Eeshita, Park, Joong -Mok, Fungura, Fadzai, Shinar, Joseph, & Shinar, Ruth. Oxygen and relative humidity monitoring with films tailored for enhanced photoluminescence. United States. https://doi.org/10.1016/j.aca.2014.10.035
Cui, Weipan, Liu, Rui, Manna, Eeshita, Park, Joong -Mok, Fungura, Fadzai, Shinar, Joseph, and Shinar, Ruth. Fri .
"Oxygen and relative humidity monitoring with films tailored for enhanced photoluminescence". United States. https://doi.org/10.1016/j.aca.2014.10.035. https://www.osti.gov/servlets/purl/1225526.
@article{osti_1225526,
title = {Oxygen and relative humidity monitoring with films tailored for enhanced photoluminescence},
author = {Cui, Weipan and Liu, Rui and Manna, Eeshita and Park, Joong -Mok and Fungura, Fadzai and Shinar, Joseph and Shinar, Ruth},
abstractNote = {In this study, approaches to generate porous or doped sensing films, which significantly enhance the photoluminescence (PL) of oxygen optical sensors, and thus improve the signal-to-noise (S/N) ratio, are presented. Tailored films, which enable monitoring the relative humidity (RH) as well, are also presented. Effective porous structures, in which the O2-sensitive dye Pt octaethylporphyrin (PtOEP) or the Pd analog PdOEP was embedded, were realized by first generating blend films of polyethylene glycol (PEG) with polystyrene (PS) or with ethyl cellulose (EC), and then immersing the dried films in water to remove the water-soluble PEG. This approach creates pores (voids) in the sensing films. The dielectric contrast between the films’ constituents and the voids increases photon scattering, which in turn increases the optical path of the excitation light within the film, and hence light absorption by the dye, and its PL. Optimized sensing films with a PEG:PS ratio of 1:4 (PEG’s molecular weight Mw ~8000) led to ~4.4× enhancement in the PL (in comparison to PS films). Lower Mw ~200 PEG with a PEG:EC ratio of 1:1 led to a PL enhancement of ~4.7×. Film-dependent PL enhancements were observed at all oxygen concentrations. The strong PL enhancement enables (i) using lower dye (luminophore) concentrations, (ii) reducing power consumption and enhancing the sensor’s operational lifetime when using organic light emitting diodes (OLEDs) as excitation sources, (iii) improving performance when using compact photodetectors with no internal gain, and (iv) reliably extending the dynamic range.},
doi = {10.1016/j.aca.2014.10.035},
journal = {Analytica Chimica Acta},
number = C,
volume = 853,
place = {United States},
year = {Fri Oct 31 00:00:00 EDT 2014},
month = {Fri Oct 31 00:00:00 EDT 2014}
}
Web of Science
Works referenced in this record:
New oxygen sensors and their application to biosensing
journal, October 1995
- Papkovsky, Dmitri B.
- Sensors and Actuators B: Chemical, Vol. 29, Issue 1-3
Optical Sensor for Oxygen Using a Porphyrin-doped Sol–Gel Glass
journal, January 1997
- Lee, Sang-Kyung; Okura, Ichiro
- The Analyst, Vol. 122, Issue 1
Controlling the Response Characteristics of Luminescent Porphyrin Plastic Film Sensors for Oxygen
journal, November 1997
- Mills, Andrew; Lepre, Anne
- Analytical Chemistry, Vol. 69, Issue 22
Response characteristics of thin film oxygen sensors, Pt and Pd octaethylporphyrins in polymer films
journal, February 2002
- Douglas, P.; Eaton, K.
- Sensors and Actuators B: Chemical, Vol. 82, Issue 2-3
Probes and Polymers for Optical Sensing of Oxygen
journal, September 2003
- Amao, Yutaka
- Microchimica Acta, Vol. 143, Issue 1
Organic light-emitting devices (OLEDs) and OLED-based chemical and biological sensors: an overview
journal, June 2008
- Shinar, Joseph; Shinar, Ruth
- Journal of Physics D: Applied Physics, Vol. 41, Issue 13
Data analysis and aging in phosphorescent oxygen-based sensors
journal, April 2010
- Cai, Yuankun; Smith, Alex; Shinar, Joseph
- Sensors and Actuators B: Chemical, Vol. 146, Issue 1
Indicators for optical oxygen sensors
journal, November 2012
- Quaranta, Michela; Borisov, Sergey M.; Klimant, Ingo
- Bioanalytical Reviews, Vol. 4, Issue 2-4
Optical methods for sensing and imaging oxygen: materials, spectroscopies and applications
journal, January 2014
- Wang, Xu-dong; Wolfbeis, Otto S.
- Chem. Soc. Rev., Vol. 43, Issue 10
Structurally integrated organic light emitting device-based sensors for gas phase and dissolved oxygen
journal, May 2006
- Shinar, Ruth; Zhou, Zhaoqun; Choudhury, Bhaskar
- Analytica Chimica Acta, Vol. 568, Issue 1-2
Polymer/Silica Composite Films as Luminescent Oxygen Sensors
journal, March 2001
- Lu, Xin; Manners, Ian; Winnik, Mitchell A.
- Macromolecules, Vol. 34, Issue 6
Luminescence Quenching in Polymer/Filler Nanocomposite Films Used in Oxygen Sensors
journal, October 2001
- Lu, Xin; Winnik, Mitchell A.
- Chemistry of Materials, Vol. 13, Issue 10
Enhanced Photoluminescence of Oxygen Sensing Films through Doping with High Dielectric Constant Particles
journal, October 2007
- Zhou, Z.; Shinar, R.; Allison, A. J.
- Advanced Functional Materials, Vol. 17, Issue 17
Luminescence-based oxygen sensor structurally integrated with an organic light-emitting device excitation source and an amorphous Si-based photodetector
journal, June 2006
- Shinar, Ruth; Ghosh, Debju; Choudhury, Bhaskar
- Journal of Non-Crystalline Solids, Vol. 352, Issue 9-20
Amorphous and nanocrystalline p–i–n Si and Si,Ge photodetectors for structurally integrated O2 sensors
journal, May 2008
- Ghosh, Debju; Shinar, Ruth; Dalal, Vikram
- Journal of Non-Crystalline Solids, Vol. 354, Issue 19-25
Multianalyte sensor array based on an organic light emitting diode platform
journal, September 2008
- Cai, Yuankun; Shinar, Ruth; Zhou, Zhaoqun
- Sensors and Actuators B: Chemical, Vol. 134, Issue 2
Polythiophene-Fullerene Based Photodetectors: Tuning of Spectral Response and Application in Photoluminescence Based (Bio)Chemical Sensors
journal, August 2010
- Nalwa, Kanwar S.; Cai, Yuankun; Thoeming, Aaron L.
- Advanced Materials, Vol. 22, Issue 37
LED–LED portable oxygen gas sensor
journal, August 2012
- Perez de Vargas-Sansalvador, I. M.; Fay, C.; Fernandez-Ramos, M. D.
- Analytical and Bioanalytical Chemistry, Vol. 404, Issue 10
A luminescence lifetime-based capillary oxygen sensor utilizing monolithically integrated organic photodiodes
journal, January 2013
- Lamprecht, Bernhard; Tschepp, Andreas; Čajlaković, Merima
- The Analyst, Vol. 138, Issue 20
Integrated Optoelectronic Devices Based on Conjugated Polymers
journal, June 1998
- Sirringhaus, H.
- Science, Vol. 280, Issue 5370
Nanophase-Separated Polymer Films as High-Performance Antireflection Coatings
journal, January 1999
- Walheim, S.
- Science, Vol. 283, Issue 5401
Microfabricating Conjugated Polymer Actuators
journal, November 2000
- Jager, E. W. H.
- Science, Vol. 290, Issue 5496
Porous Polymer Films with Gradient-Refractive-Index Structure for Broadband and Omnidirectional Antireflection Coatings
journal, January 2010
- Li, Xiao; Gao, Junpeng; Xue, Longjian
- Advanced Functional Materials, Vol. 20, Issue 2
Selective Deposition of Proteins and Cells in Arrays of Microwells
journal, May 2001
- Ostuni, Emanuele; Chen, Christopher S.; Ingber, Donald E.
- Langmuir, Vol. 17, Issue 9
Surface-induced structure formation of polymer blends on patterned substrates
journal, February 1998
- Böltau, Martin; Walheim, Stefan; Mlynek, Jürgen
- Nature, Vol. 391, Issue 6670, p. 877-879
Convection-Induced Patterns in Phase-Separating Polymeric Fluids
journal, October 1998
- Mitov, Zdravko; Kumacheva, Eugenia
- Physical Review Letters, Vol. 81, Issue 16
Breath Figures as a Dynamic Templating Method for Polymers and Nanomaterials
journal, April 2006
- Bunz, U. H. F.
- Advanced Materials, Vol. 18, Issue 8
Periodic Porous Stripe Patterning in a Polymer Blend Film Induced by Phase Separation during Spin-Casting
journal, July 2008
- Kim, Jae-Kyung; Taki, Kentaro; Nagamine, Shinsuke
- Langmuir, Vol. 24, Issue 16
Phase separation induced ordered patterns in thin polymer blend films
journal, April 2012
- Xue, Longjian; Zhang, Jilin; Han, Yanchun
- Progress in Polymer Science, Vol. 37, Issue 4
Soft holographic interference lithography microlens for enhanced organic light emitting diode light extraction
journal, January 2011
- Park, Joong-Mok; Gan, Zhengqing; Leung, Wai Y.
- Optics Express, Vol. 19, Issue S4
Extremely Efficient Indium-Tin-Oxide-Free Green Phosphorescent Organic Light-Emitting Diodes
journal, July 2012
- Cai, Min; Ye, Zhuo; Xiao, Teng
- Advanced Materials, Vol. 24, Issue 31
Organic Light-Emitting Diode Sensing Platform: Challenges and Solutions
journal, October 2011
- Liu, Rui; Cai, Yuankun; Park, Joong-Mok
- Advanced Functional Materials, Vol. 21, Issue 24
MoO 3 as combined hole injection layer and tapered spacer in combinatorial multicolor microcavity organic light emitting diodes
journal, August 2011
- Liu, Rui; Xu, Chun; Biswas, Rana
- Applied Physics Letters, Vol. 99, Issue 9
Effects of Polymer Matrixes on the Time-Resolved Luminescence of a Ruthenium Complex Quenched by Oxygen
journal, March 1995
- Draxler, Sonja; Lippitsch, Max E.; Klimant, Ingo
- The Journal of Physical Chemistry, Vol. 99, Issue 10
Effect of humidity on the response characteristics of luminescent PtOEP thin film optical oxygen sensors
journal, February 2002
- Eaton, K.; Douglas, P.
- Sensors and Actuators B: Chemical, Vol. 82, Issue 1
Effect of Lumophore and Plasticiser Concentration on The Heterogeneity of Oxygen Quenching in Thin Film Oxygen Sensors
journal, May 2006
- Hughes, Victoria A.; Douglas, Peter
- Journal of Fluorescence, Vol. 16, Issue 3
A simple colorimetric luminescent oxygen sensor using a green LED with Pt octaethylporphyrin in ethyl cellulose as the oxygen-responsive element
journal, December 2008
- Ricketts, Stephen R.; Douglas, Peter
- Sensors and Actuators B: Chemical, Vol. 135, Issue 1
Titanium-containing mesoporous molecular sieves for catalytic oxidation of aromatic compounds
journal, March 1994
- Tanev, Peter T.; Chibwe, Malama; Pinnavaia, Thomas J.
- Nature, Vol. 368, Issue 6469
Polymer-Fullerene Bulk-Heterojunction Solar Cells
journal, August 2010
- Brabec, Christoph J.; Gowrisanker, Srinivas; Halls, Jonathan J. M.
- Advanced Materials, Vol. 22, Issue 34
Preparation of a Unique Microporous Structure via Two Step Phase Separation in the Course of Drying a Ternary Polymer Solution
journal, November 2007
- Kim, Jae-Kyung; Taki, Kentaro; Ohshima, Masahiro
- Langmuir, Vol. 23, Issue 24
Microporous phase-separated films of polymer blends for enhanced outcoupling of light from OLEDs
journal, January 2011
- Liu, Rui; Ye, Zhuo; Park, Joong-Mok
- Optics Express, Vol. 19, Issue S6
Multiple approaches for enhancing all-organic electronics photoluminescent sensors: Simultaneous oxygen and pH monitoring
journal, May 2013
- Liu, Rui; Xiao, Teng; Cui, Weipan
- Analytica Chimica Acta, Vol. 778
Synthesis and phase transition of cellulose- graft -poly(ethylene glycol) copolymers
journal, November 2008
- Li, Yanxiang; Liu, Ruigang; Huang, Yong
- Journal of Applied Polymer Science, Vol. 110, Issue 3
Control of mesh pattern of surface corrugation via rate of solvent evaporation in solution casting of polymer film in the presence of convection
journal, May 2002
- Sakurai, Shinichi; Furukawa, Chizuko; Okutsu, Akihiko
- Polymer, Vol. 43, Issue 11
Tunable ordered droplets induced by convection in phase-separating P2VP/PS blend film
journal, November 2004
- Cui, Liang; Wang, Hanfu; Ding, Yan
- Polymer, Vol. 45, Issue 24
Photophysics of an electrophosphorescent platinum (II) porphyrin in solid films
journal, April 2005
- Kalinowski, J.; Stampor, W.; Szmytkowski, J.
- The Journal of Chemical Physics, Vol. 122, Issue 15
The Separation of Cu 2+ and Ni 2+ from Fe 3+ Ions by Complexation with Alginic Acid and Using a Suitable Membrane
journal, January 1998
- Scedil;olpan, Dilek; Şahan, Mehmet
- Separation Science and Technology, Vol. 33, Issue 6
Selection of silicone polymer matrix for optical gas sensing
journal, October 1995
- He, Huarui; Fraatz, Robert J.; Leiner, Marc J. P.
- Sensors and Actuators B: Chemical, Vol. 29, Issue 1-3
An integrated micro-volume fiber-optic sensor for oxygen determination in exhaled breath based on iridium(iii) complexes immobilized in fluorinated xerogels
journal, January 2013
- Xiong, Yan; Ye, Zhongbin; Xu, Jing
- The Analyst, Vol. 138, Issue 6
Phosphorescent oxygen sensors produced by spot-crazing of polyphenylenesulfide films
journal, January 2014
- Toncelli, Claudio; Arzhakova, Olga V.; Dolgova, Alla
- J. Mater. Chem. C, Vol. 2, Issue 38
Works referencing / citing this record:
The effect of the surface coating of a strontium mono-aluminate europium dysprosium-based (SrAl 2 O 4 :Eu 2+ ,Dy 3+ ) phosphor by polyethylene (PE), polystyrene (PS) and their dual system on the photoluminescence properties of the pigment
journal, January 2019
- Tayebi, Masumeh; Ostad Movahed, Saeed; Ahmadpour, Ali
- RSC Advances, Vol. 9, Issue 66