skip to main content
OSTI.GOV title logo U.S. Department of Energy
Office of Scientific and Technical Information

Title: 2D micromodel study of clogging behavior of fine-grained particles associated with gas hydrate production in NGHP-02 gas hydrate reservoir sediments

Abstract

Fine-grained particles (fines) commonly coexist with coarse-grained sediments that host gas hydrate. These fines can be mobilized by liquid and gas flow during gas hydrate production. Once mobilized, fines can clog pore throats and reduce reservoir permeability. Even where particle sizes are smaller than pore-throat sizes, clogs can form due to clusters of fines. For certain types of fines, particularly swelling clays, cluster sizes depend on pore-fluid chemistry, which changes as pore-fluid freshens during gas hydrate dissociation. Fines can also be concentrated by a moving gas/liquid interface, increasing the chances of pore-throat clogging regardless of fines type. To test the relative significance of these clogging mechanisms, 2D micromodel experiments have been conducted with different pore-throat widths (20, 40, 60 and 100 µm), single-phase pore-fluids (deionized water and 2M-sodium-chloride solution), and moving gas/liquid interfaces on specimens from Sites NGHP-02-09 and NGHP-02-16 (NGHP-02: National Gas Hydrate Program Expedition 02) as well as a selection of pure fines (silica silt, mica, calcium carbonate, diatoms, kaolin, and bentonite). Clogging depended on the ratio of particle-to-pore throat size, and also on pore-fluid chemistry because the pore-fluid chemistry changes effectively increased or decreased the fine’s cluster size relative to the pore-throat width. These interactions can bemore » predicted based on the fine’s electrical sensitivity (defined by Jang and Santamarina, 2016). The fine-grained sediment component (grain size < 75 μm) from the primary gas hydrate reservoir layers at Sites NGHP-02-09 and -16 show clogging via blocking or size exclusion (sieving) due to the large particles. Clogs also formed due to bridging or blocking by clusters of the smaller particles. In conclusion, clogging generally occurred for pore-water sediment concentrations so low (0.2% by mass or less), that it was difficult to resolve the enhanced clogging in the presence of the gas/liquid meniscus.« less

Authors:
 [1];  [2]; ORCiD logo [3]; ORCiD logo [4];  [5];  [6]
  1. Oklahoma State Univ., Stillwater, OK (United States). Chemical Engineering
  2. U.S. Geological Survey, Woods Hole, MA (United States). Integrated Statistics Inc.
  3. Chungbuk National Univ., Cheongju, Chungbuk (South Korea). School of Civil Engineering
  4. U.S. Geological Survey, Woods Hole, MA (United States)
  5. U.S. Geological Survey, Denver, CO (United States)
  6. Oil and Natural Gas Corporation, Panvel, Navi Mumbai, (India)
Publication Date:
Research Org.:
Louisiana State Univ., Baton Rouge, LA (United States)
Sponsoring Org.:
USDOE Office of Fossil Energy (FE)
OSTI Identifier:
1469997
Alternate Identifier(s):
OSTI ID: 1636299
Grant/Contract Number:  
FE0028966; FE00-28966
Resource Type:
Journal Article: Accepted Manuscript
Journal Name:
Marine and Petroleum Geology
Additional Journal Information:
Journal Volume: 108; Related Information: U.S. Geological Survey data release, https://doi.org/10.5066/P9PZ5M7E.; Journal ID: ISSN 0264-8172
Publisher:
Elsevier
Country of Publication:
United States
Language:
English
Subject:
37 INORGANIC, ORGANIC, PHYSICAL, AND ANALYTICAL CHEMISTRY; 09 BIOMASS FUELS; NGHP; gas hydrate; fine-grained sediment; interparticle forces; pore-fluid chemistry; sediment fabric; fines migration; clogging; gas/liquid meniscus; micromodel

Citation Formats

Cao, Shuang C., Jang, Junbong, Jung, Jongwon, Waite, William F., Collett, Timothy S., and Kumar, Pushpendra. 2D micromodel study of clogging behavior of fine-grained particles associated with gas hydrate production in NGHP-02 gas hydrate reservoir sediments. United States: N. p., 2018. Web. doi:10.1016/j.marpetgeo.2018.09.010.
Cao, Shuang C., Jang, Junbong, Jung, Jongwon, Waite, William F., Collett, Timothy S., & Kumar, Pushpendra. 2D micromodel study of clogging behavior of fine-grained particles associated with gas hydrate production in NGHP-02 gas hydrate reservoir sediments. United States. https://doi.org/10.1016/j.marpetgeo.2018.09.010
Cao, Shuang C., Jang, Junbong, Jung, Jongwon, Waite, William F., Collett, Timothy S., and Kumar, Pushpendra. 2018. "2D micromodel study of clogging behavior of fine-grained particles associated with gas hydrate production in NGHP-02 gas hydrate reservoir sediments". United States. https://doi.org/10.1016/j.marpetgeo.2018.09.010. https://www.osti.gov/servlets/purl/1469997.
@article{osti_1469997,
title = {2D micromodel study of clogging behavior of fine-grained particles associated with gas hydrate production in NGHP-02 gas hydrate reservoir sediments},
author = {Cao, Shuang C. and Jang, Junbong and Jung, Jongwon and Waite, William F. and Collett, Timothy S. and Kumar, Pushpendra},
abstractNote = {Fine-grained particles (fines) commonly coexist with coarse-grained sediments that host gas hydrate. These fines can be mobilized by liquid and gas flow during gas hydrate production. Once mobilized, fines can clog pore throats and reduce reservoir permeability. Even where particle sizes are smaller than pore-throat sizes, clogs can form due to clusters of fines. For certain types of fines, particularly swelling clays, cluster sizes depend on pore-fluid chemistry, which changes as pore-fluid freshens during gas hydrate dissociation. Fines can also be concentrated by a moving gas/liquid interface, increasing the chances of pore-throat clogging regardless of fines type. To test the relative significance of these clogging mechanisms, 2D micromodel experiments have been conducted with different pore-throat widths (20, 40, 60 and 100 µm), single-phase pore-fluids (deionized water and 2M-sodium-chloride solution), and moving gas/liquid interfaces on specimens from Sites NGHP-02-09 and NGHP-02-16 (NGHP-02: National Gas Hydrate Program Expedition 02) as well as a selection of pure fines (silica silt, mica, calcium carbonate, diatoms, kaolin, and bentonite). Clogging depended on the ratio of particle-to-pore throat size, and also on pore-fluid chemistry because the pore-fluid chemistry changes effectively increased or decreased the fine’s cluster size relative to the pore-throat width. These interactions can be predicted based on the fine’s electrical sensitivity (defined by Jang and Santamarina, 2016). The fine-grained sediment component (grain size < 75 μm) from the primary gas hydrate reservoir layers at Sites NGHP-02-09 and -16 show clogging via blocking or size exclusion (sieving) due to the large particles. Clogs also formed due to bridging or blocking by clusters of the smaller particles. In conclusion, clogging generally occurred for pore-water sediment concentrations so low (0.2% by mass or less), that it was difficult to resolve the enhanced clogging in the presence of the gas/liquid meniscus.},
doi = {10.1016/j.marpetgeo.2018.09.010},
url = {https://www.osti.gov/biblio/1469997}, journal = {Marine and Petroleum Geology},
issn = {0264-8172},
number = ,
volume = 108,
place = {United States},
year = {Tue Sep 11 00:00:00 EDT 2018},
month = {Tue Sep 11 00:00:00 EDT 2018}
}

Journal Article:

Citation Metrics:
Cited by: 30 works
Citation information provided by
Web of Science

Save / Share:

Works referenced in this record:

Experimental investigation of pore clogging by microparticles: Evidence for a critical flux density of particle yielding arches and deposits
journal, November 2012


Geologic implications of gas hydrates in the offshore of India: Results of the National Gas Hydrate Program Expedition 01
journal, December 2014


Clogging of microfluidic systems
journal, January 2017


Bulk sediment mineralogy of gas hydrate reservoir at the East Nankai offshore production test site
journal, September 2015


Analysis of deep bed filtration data: Modeling as a birth-death process
journal, November 1985


Formation damage due to fines migration and its remedial methods
journal, December 2016


Entrainment and Deposition of Fine Particles in Porous Media
journal, December 1982


Depressurization‐Induced Fines Migration in Sediments Containing Methane Hydrate: X‐Ray Computed Tomography Imaging Experiments
journal, April 2018


Computer simulation of particle transport processes in flow through porous media
journal, January 1991


Film and line tension effects on the attachment of particles to an interface
journal, July 1986


Fines Classification Based on Sensitivity to Pore-Fluid Chemistry
journal, April 2016


Closure to “Fines Classification Based on Sensitivity to Pore-Fluid Chemistry” by Junbong Jang and J. Carlos Santamarina
journal, July 2017


Impact of Pore Fluid Chemistry on Fine-Grained Sediment Fabric and Compressibility
journal, July 2018


Gas Production from Hydrate-Bearing Sediments: The Role of Fine Particles
journal, December 2011


A microfluidic pore model to study the migration of fine particles in single-phase and multi-phase flows in porous media
journal, June 2017


India National Gas Hydrate Program Expedition-02: Operational and technical summary
journal, October 2019


Poly(dimethylsiloxane) as a Material for Fabricating Microfluidic Devices
journal, April 2002


Water sensitivity of sandstones containing swelling and non-swelling clays
journal, June 1993


Formation Fines and Factors Controlling Their Movement in Porous Media
journal, February 1979


Experimental study of mud erosion at the interface of an artificial sand-mud alternate layer
journal, August 2016


Existence of a critical particle concentration in plugging of a packed bed
journal, April 1998


A network model for deep bed filtration of solid particles and emulsion drops
journal, November 1988


Fines migration in porous media
journal, October 1987


On the electrostatic interaction in macroionic solutions
journal, December 1984


Particle transport in a nonuniform flow field: Retardation and clogging
journal, June 2007


Clogging: bridge formation and vibration-based destabilization
journal, February 2008


Experimental Investigation of the Effects of Suffusion on Physical and Geomechanic Characteristics of Sandy Soils
journal, September 2012


Works referencing / citing this record:

An analytical approach to investigate formation damage caused by underbalanced drilling performances
journal, June 2019


Mathematical modeling of formation damage effect during underbalanced drilling operations
journal, June 2019