Separation of switchgrass bio-oil by water/organic solvent addition and pH adjustment

Park, Lydia Kyoung-Eun; Ren, Shoujie; Yiacoumi, Sotira; Ye, X. Philip; Borole, Abhijeet P.; Tsouris, Costas

doi:10.1021/acs.energyfuels.5b02537

Title: Separation of switchgrass bio-oil by water/organic solvent addition and pH adjustment

Journal Article · Fri Jan 29 00:00:00 EST 2016 · Energy and Fuels

DOI:https://doi.org/10.1021/acs.energyfuels.5b02537· OSTI ID:1240548

Park, Lydia Kyoung-Eun ^[1]; Ren, Shoujie ^[2]; Yiacoumi, Sotira ^[1]; Ye, X. Philip ^[2]; Borole, Abhijeet P. ^[3]; Tsouris, Costas ^[4]

Georgia Inst. of Technology, Atlanta, GA (United States)
Univ. of Tennessee, Knoxville, TN (United States). Institute of Agriculture
Univ. of Tennessee, Knoxville, TN (United States). Bredesen Center for Interdisciplinary Research and Education; Oak Ridge National Lab. (ORNL), Oak Ridge, TN (United States)
Georgia Inst. of Technology, Atlanta, GA (United States); Oak Ridge National Lab. (ORNL), Oak Ridge, TN (United States)

Applications of bio-oil are limited by its challenging properties including high moisture content, low pH, high viscosity, high oxygen content, and low heating value. Separation of switchgrass bio-oil components by adding water, organic solvents (hexadecane and octane), and sodium hydroxide may help to overcome these issues. Acetic acid and phenolic compounds were extracted in aqueous and organic phases, respectively. Polar chemicals, such as acetic acid, did not partition in the organic solvent phase. Acetic acid in the aqueous phase after extraction is beneficial for a microbial-electrolysis-cell application to produce hydrogen as an energy source for further hydrodeoxygenation of bio-oil. Organic solvents extracted more chemicals from bio-oil in combined than in sequential extraction; however, organic solvents partitioned into the aqueous phase in combined extraction. When sodium hydroxide was added to adjust the pH of aqueous bio-oil, organic-phase precipitation occurred. As the pH was increased, a biphasic aqueous/organic dispersion was formed, and phase separation was optimized at approximately pH 6. The neutralized organic bio-oil had approximately 37% less oxygen and 100% increased heating value than the initial centrifuged bio-oil. In conclusion, the less oxygen content and increased heating value indicated a significant improvement of the bio-oil quality through neutralization.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Oak Ridge National Laboratory (ORNL), Oak Ridge, TN (United States)

Sponsoring Organization:: USDOE Office of Energy Efficiency and Renewable Energy (EERE), Sustainable Transportation Office. Bioenergy Technologies Office

Grant/Contract Number:: AC05-00OR22725

OSTI ID:: 1240548

Journal Information:: Energy and Fuels, Vol. 30, Issue 3; ISSN 0887-0624

Publisher:: American Chemical Society (ACS)Copyright Statement

Country of Publication:: United States

Language:: English

Citation Metrics:

Cited by: 34 works

Citation information provided by
Web of Science

References (25)

The Path Forward for Biofuels and Biomaterials Ragauskas, Arthur J.; Williams, Charlotte K.; Davison, Brian H. Science, Vol. 311, Issue 5760, p. 484-489 https://doi.org/10.1126/science.1114736	journal	January 2006
Biomass as feedstock for a bioenergy and bioproducts industry: The technical feasibility of a billion-ton annual supply Perlack, Robert D.; Wright, Lynn L.; Turhollow, Anthony F. https://doi.org/10.2172/1216415	report	April 2005
NiFe/γ-Al2O3: A universal catalyst for the hydrodeoxygenation of bio-oil and its model compounds Leng, Shuai; Wang, Xinde; He, Xiaobo Catalysis Communications, Vol. 41 https://doi.org/10.1016/j.catcom.2013.06.037	journal	November 2013
Supercritical CO ₂ Fractionation of Bio-oil Produced from Mixed Biomass of Wheat and Wood Sawdust Rout, P. K.; Naik, M. K.; Naik, S. N. Energy & Fuels, Vol. 23, Issue 12 https://doi.org/10.1021/ef900663a	journal	December 2009
Bio-oil upgrading by means of ethyl ester production in reactive distillation to remove water and to improve storage and fuel characteristics Junming, Xu; Jianchun, Jiang; Yunjuan, Sun Biomass and Bioenergy, Vol. 32, Issue 11 https://doi.org/10.1016/j.biombioe.2008.02.002	journal	November 2008
Biomass to Fuels Mahfud, F. H.; Melián-Cabrera, I.; Manurung, R. Process Safety and Environmental Protection, Vol. 85, Issue 5 https://doi.org/10.1205/psep07013	journal	January 2007
Upgrading of Bio-oil by Catalytic Esterification and Determination of Acid Number for Evaluating Esterification Degree Wang, Jin-Jiang; Chang, Jie; Fan, Juan Energy & Fuels, Vol. 24, Issue 5 https://doi.org/10.1021/ef1000634	journal	April 2010
Methods for mitigation of bio-oil extract toxicity Chan, Jacky K. S.; Duff, Sheldon J. B. Bioresource Technology, Vol. 101, Issue 10 https://doi.org/10.1016/j.biortech.2009.12.054	journal	May 2010
Bio-oil valorization: A review Jacobson, Kathlene; Maheria, Kalpana C.; Kumar Dalai, Ajay Renewable and Sustainable Energy Reviews, Vol. 23 https://doi.org/10.1016/j.rser.2013.02.036	journal	July 2013
Water extraction of pyrolysis oil: The first step for the recovery of renewable chemicals Vitasari, Caecilia R.; Meindersma, G. W.; de Haan, André B. Bioresource Technology, Vol. 102, Issue 14 https://doi.org/10.1016/j.biortech.2011.04.079	journal	July 2011
Effective Phase Separation of Biomass Pyrolysis Oils by Adding Aqueous Salt Solutions Song, Qin-Hua; Nie, Jun-Qi; Ren, Ming-Guang Energy & Fuels, Vol. 23, Issue 6 https://doi.org/10.1021/ef900143u	journal	June 2009
Liquid–Liquid Extraction of Biomass Pyrolysis Bio-oil Wei, Yi; Lei, Hanwu; Wang, Lu Energy & Fuels, Vol. 28, Issue 2 https://doi.org/10.1021/ef402490s	journal	February 2014
Polarity-based separation and chemical characterization of fast pyrolysis bio-oil from poultry litter Ma, Bingji; Agblevor, Foster A. Biomass and Bioenergy, Vol. 64 https://doi.org/10.1016/j.biombioe.2014.03.003	journal	May 2014
Acetic Acid Recovery from Fast Pyrolysis Oil. An Exploratory Study on Liquid-Liquid Reactive Extraction using Aliphatic Tertiary Amines Mahfud, F. H.; van Geel, F. P.; Venderbosch, R. H. Separation Science and Technology, Vol. 43, Issue 11-12 https://doi.org/10.1080/01496390802222509	journal	August 2008
Separation of acetic acid from the aqueous fraction of fast pyrolysis bio-oils using nanofiltration and reverse osmosis membranes Teella, Achyuta; Huber, George W.; Ford, David M. Journal of Membrane Science, Vol. 378, Issue 1-2 https://doi.org/10.1016/j.memsci.2011.05.036	journal	August 2011
Catalytic Conversion of Biomass by Natural Gas for Oil Quality Upgrading He, Peng; Song, Hua Industrial & Engineering Chemistry Research, Vol. 53, Issue 41 https://doi.org/10.1021/ie502272j	journal	October 2014
Hydrogen production from switchgrass via an integrated pyrolysis–microbial electrolysis process Lewis, A. J.; Ren, S.; Ye, X. Bioresource Technology, Vol. 195 https://doi.org/10.1016/j.biortech.2015.06.085	journal	November 2015
Production, separation and applications of phenolic-rich bio-oil – A review Kim, Joo-Sik Bioresource Technology, Vol. 178 https://doi.org/10.1016/j.biortech.2014.08.121	journal	February 2015
Production of renewable phenolic resins by thermochemical conversion of biomass: A review Effendi, A.; Gerhauser, H.; Bridgwater, A. V. Renewable and Sustainable Energy Reviews, Vol. 12, Issue 8 https://doi.org/10.1016/j.rser.2007.04.008	journal	October 2008
Aqueous-phase hydrodeoxygenation of bio-derived phenols to cycloalkanes Zhao, Chen; He, Jiayue; Lemonidou, Angeliki A. Journal of Catalysis, Vol. 280, Issue 1 https://doi.org/10.1016/j.jcat.2011.02.001	journal	May 2011
Hydrotreating of Phenolic Compounds Separated from Bio-oil to Alcohols Guo, Jianhua; Ruan, Renxiang; Zhang, Ying Industrial & Engineering Chemistry Research, Vol. 51, Issue 19 https://doi.org/10.1021/ie300106r	journal	May 2012
Recovery of renewable phenolic fraction from pyrolysis oil Fele Žilnik, Ljudmila; Jazbinšek, Alma Separation and Purification Technology, Vol. 86 https://doi.org/10.1016/j.seppur.2011.10.040	journal	February 2012
Multi-step separation of monophenols and pyrolytic lignins from the water-insoluble phase of bio-oil Wang, Shurong; Wang, Yurong; Cai, Qinjie Separation and Purification Technology, Vol. 122 https://doi.org/10.1016/j.seppur.2013.11.017	journal	February 2014
Surface Functionality and Carbon Structures in Lignocellulosic-Derived Biochars Produced by Fast Pyrolysis Kim, Pyoungchung; Johnson, Amy; Edmunds, Charles W. Energy & Fuels, Vol. 25, Issue 10 https://doi.org/10.1021/ef200915s	journal	October 2011
Bio-oils obtained by vacuum pyrolysis of softwood bark as a liquid fuel for gas turbines. Part I: Properties of bio-oil and its blends with methanol and a pyrolytic aqueous phase Boucher, M. E.; Chaala, A.; Roy, C. Biomass and Bioenergy, Vol. 19, Issue 5 https://doi.org/10.1016/S0961-9534(00)00043-X	journal	November 2000

Cited By (1)

Recent advances in the catalytic hydrodeoxygenation of bio-oil Lee, Heejin; Kim, Young-Min; Lee, In-Gu Korean Journal of Chemical Engineering, Vol. 33, Issue 12 https://doi.org/10.1007/s11814-016-0214-3	journal	September 2016

Similar Records

pH Neutralization of Aqueous Bio-Oil from Switchgrass Intermediate Pyrolysis Using Process Intensification Devices

Journal Article · Thu Jul 20 00:00:00 EDT 2017 · Energy and Fuels · OSTI ID:1240548

Park, Lydia Kyoung-Eun; Ren, Shoujie; Yiacoumi, Sotira; +3 more

Analysis of switchgrass-derived bio-oil and associated aqueous phase generated in a semi-pilot scale auger pyrolyzer

Journal Article · Wed Mar 30 00:00:00 EDT 2016 · Journal of Analytical and Applied Pyrolysis · OSTI ID:1240548

Ren, Shoujie; Ye, X. Philip; Borole, Abhijeet P.; +2 more

Contribution of acidic components to the total acid number (TAN) of bio-oil

Journal Article · Tue Mar 28 00:00:00 EDT 2017 · Fuel · OSTI ID:1240548

Park, Lydia K-E.; Liu, Jiaojun; Yiacoumi, Sotira; +2 more

Related Subjects

09 BIOMASS FUELS

Title: Separation of switchgrass bio-oil by water/organic solvent addition and pH adjustment

Citation Formats

References (25)

Cited By (1)

Similar Records

Related Subjects