Use of a utility model combustion facility to determine the combustion characteristics of several coals and coal blends for potential use in a 625 MW boiler
A combustion research program was developed jointly among Consolidation Coal Company (Consol), New York State Electric and Gas (NYSEG), and Conoco Coal Research Division (CCRD) to test potential fuels for use in NYSEG's 625 MW Somerset boiler due to come on-line in October 1984. The tests were performed in the Conoco/Consol 1.5 MM Btu/hr combustor which is intended to simulate the configuration and operating conditions of a typical utility boiler. The combustion performance of five coals and one coal blend was determined at four specific operating conditions: volumetric heat release rates of 12,000 and 16,000 Btu/hr ft/sup 3/ with 2.5 and 3.2% O/sub 2/ measured in the flue gas at each heat release rate. Measurements made during each test included: flue gas species (O/sub 2/, CO/sub 2/, CO, NO /sub x/, SO/sub 2/), furnace gas exit temperature, firebox wall temperatures, and heat transfer rates through the slag panel and fouling probes. Samples included: fly ash, bottom ash, slagging and fouling deposits, and fuel (pulverized coal). Flame patterns during each test and deposits in the firebox and radiant sections after a run were video recorded for each fuel tested.
- Research Organization:
- Conoco Inc.
- OSTI ID:
- 5079343
- Report Number(s):
- CONF-831112-
- Journal Information:
- Coal Technol. (Houston); (United States), Vol. 3; Conference: Coal technology '83 - international coal utilization convention, Houston, TX, USA, 15 Nov 1983
- Country of Publication:
- United States
- Language:
- English
Similar Records
Preparation and combustion of coal-water fuel from the Sin Pun coal deposit, southern Thailand
Combustion characteristics of fine-ground coal. Project 61052 quarterly technical report, December 1, 1981-February 28, 1982. [Effect of particle size; flame characteristics]
Related Subjects
20 FOSSIL-FUELED POWER PLANTS
COAL
COMBUSTION PRODUCTS
COMBUSTION PROPERTIES
COMPARATIVE EVALUATIONS
FLUE GAS
CHEMICAL COMPOSITION
BOILER FUELS
BOILERS
COMBUSTION KINETICS
COMBUSTORS
DEPOSITS
ELECTRIC UTILITIES
FLY ASH
FOULING
MATERIALS TESTING
POWER RANGE 100-1000 MW
SIMULATION
AEROSOL WASTES
ASHES
CARBONACEOUS MATERIALS
CHEMICAL REACTION KINETICS
ENERGY SOURCES
FOSSIL FUELS
FUELS
GASEOUS WASTES
KINETICS
MATERIALS
PUBLIC UTILITIES
REACTION KINETICS
RESIDUES
TESTING
WASTES
014000* - Coal
Lignite
& Peat- Combustion
200104 - Fossil-Fueled Power Plants- Components